Professional Documents
Culture Documents
Revision Test Trigonometry
Revision Test Trigonometry
Revision Test Trigonometry
Trigonometry( Revision Test) Max. Marks-45 Submit your answer sheet to the substitution
teacher.
SECTION A
1. [Maximum mark: 6]
Ileana was given the task to construct a wooden triangle ABC subject to the following
specifications:
the side AB is 13 cm
the side AC is 10 cm
the angle is 28°
the triangle has the smallest possible area
(a) Find the length of the third wooden side that Ileana will need.
[4]
(b) Find the area of this triangle. [2]
2
2.[Maximum mark: 7]
The following three-dimensional diagram shows a vertical flagpole AD on horizontal
ground. The distance between the points B and C is 10 m. It is also given that BD =
12 m, CD = 15 m.
60°
12 m
15 m
30o
10m
............................................................................
............................................................................
............................................................................
............................................................................
............................................................................
............................................................................
............................................................................
............................................................................
(a)
Turn over
3
3. [Maximum mark: 7]
Thalia sails her boat from port A on a bearing of 070°. She sails a distance of 50 km to
position B. At B she decides to change direction on a bearing of 010°. She sails a
distance of 50 km to reach position C.
(a) Sketch a diagram to represent the information above. [1]
(b) Find the distance from port A to the final Thalia’s position C. [4]
(c) Find the bearing of the course Thalia should follow to go directly from port A to C.
[2]
............................................................................
............................................................................
............................................................................
............................................................................
............................................................................
............................................................................
............................................................................
............................................................................
............................................................................
............................................................................
............................................................................
(d)
4
Turn over
5
Section B
Answer all questions in the answer booklet provided. Please start each question on a new page.
3m
Seti wants to construct a solid from a cylinder from which a wedge was removed, as shown in
the following diagram. The length of the cylinder is 10m and the cross-section of the solid is
as in the diagram above.
3m
10 m
5.
C)