Professional Documents
Culture Documents
Requirements For BG96 Sensor
Requirements For BG96 Sensor
Power:
1 x Connector (1x3) for battery Lithium ion 4.2V: Vbat, GND, temp
1 x Charger IC (<=1A): TBD
1 x LDO 3.3V for ESP32, sensors, camera (consume <1A): XC6210B332PR-G
1 x Power switch IC for LTE, control on/off by ESP32: TBD
1 x Power switch IC for sensors: Temp-humi-light-rain, control on/off by ESP32: TBD
1 x Power switch IC for Camera: TBD
1 x LDO 2.8V for Camera (consume <100mA): TBD
1 x LDO 1.2V for Camera (consume <100mA): TBD
Power Distribution as bellow:
2. BG96 module
1 x IPEX external antenna for LTE
1 x IPEX external antenna for GPS
1 x 4 pin header for firmware update
Communication with ESP32 via UART
Translator IC for logic compatible
3. ESP32: ESP32-WROVER-IE-N4R8
1 x USB type C for update firmware (USB type C power for battery charger)
https://nshopvn.com/product/jack-type-c-4-day-co-nap-chong-nuoc/
1 x USB to UART IC: CH340 (optional if board size is small)
4. Camera: OV2640
1 x FPC connector (check part number again): AFC07-S24FCA-00
5. 1 x Connector (1x4) for Temp – Humi sensor (SHTxxx)
I2C1 connect to ESP32
6. 1 x Connector (1x4) for Light sensor (BH1750)
I2C2 connect to ESP32
Below is reference for 3 and 4: