Professional Documents
Culture Documents
Replacing Left or Right Output Shaft
Replacing Left or Right Output Shaft
REP-REP-RAF0131-3160000_ALLRAD V.6 Removing and installing/replacing left or right output
shaft, VIN: C778822
Mileage 0 km
31 60 000 Removing and
installing/replacing left or right
output shaft
Necessary preliminary work:
l Remove stiffening plate
l Remove swivel bearing.
l Remove spring strut.
Important!
Risk of damage!
Secure output shaft against falling out.
Installing the output shaft:
l Check gaiter and renew if necessary.
l Renew output shaft circlip (1).
l Renew radial shaft seal on front axle differential
and bearing support.
l Coat highlighted contact surface (2) of output shaft
with approved front axle gearbox oil.
3/28/2017 2/3
Note:
The installation protective ring (1) serves to protect the
sealing lips of the radial shaft seal (2) when installing the
output shaft.
Important!
When installing output shaft, make sure that tripod
does not fall into gaiter.
Important!
Note on installation for spur gearing must be
observed without fail!
Installation note:
l Spur gearing of wheel bearing (1) and output shaft
(2) must be installed tooth in tooth!
3/28/2017 3/3