Professional Documents
Culture Documents
1 (4 (Trifluoromethyl) Cyclohexyl) Methanamine
1 (4 (Trifluoromethyl) Cyclohexyl) Methanamine
1. PRODUCT
CAS-No.: 361393-85-3
1.2 Relevant identified uses of the substance or mixture and uses advised against
Identified uses : Laboratory chemicals, Synthesis of substances
2. HAZARDS IDENTIFICATION
For the full text of the H-Statements mentioned in this Section, see Section 16.
Pictogram
3. COMPOSITION/INFORMATION ON INGREDIENTS
3.1 Substances
Formula: C8H14F3N
Molecular weight: 181.20 g/mol
CAS-No.: 361393-85-3
Hazardous components
1
Component Classification Concentration
[4-(trifluoromethyl)cyclohexyl]methanamine
Skin Corr. 1B; Eye Dam. 1; Aquatic Acute 1; Aquatic <= 100 %
Chronic 1; H314, H318, H410
For the full text of the H-Statements mentioned in this Section, see Section 16.
General advice
Consult a physician. Show this safety data sheet to the doctor in attendance.Move out of dangerous area.
If inhaled
If breathed in, move person into fresh air. If not breathing, give artificial respiration. Consult a physician.
In case of skin contact
Take off contaminated clothing and shoes immediately. Wash off with soap and plenty of water. Consult a physician.
In case of eye contact
Rinse thoroughly with plenty of water for at least 15 minutes and consult a physician.Continue rinsing eyes during
transport to hospital.
If swallowed
Do NOT induce vomiting. Never give anything by mouth to an unconscious person. Rinse mouth with water. Consult a
physician.
4.2 Most important symptoms and effects, both acute and delayed
The most important known symptoms and effects are described in the labelling (see section 2.2) and/or in section 11
4.2 Indication of any immediate medical attention and special treatment needed
No data available
5. FIREFIGHTING MEASURES
must be avoided.
2
Soak up with inert absorbent material and dispose of as hazardous waste. Keep in suitable, closed containers for
disposal.
workday.
3
Initial boiling point and boiling range No data available
Flash point Not applicable
Evaporation rate No data available
Flammability (solid, gas) No data available
Upper/lower flammability or explosive limits No data available
Vapour pressure No data available
Vapour density No data available
Relative density No data available
Water solubility No data available
Partition coefficient: n-octanol/water log Pow: 1.873
Auto-ignition temperature No data available
Decomposition temperature No data available
Viscosity No data available
Explosive properties No data available
Oxidizing properties No data available
No data available
10.1 Reactivity
No data available
No data available
No data available
Acute toxicity
No data available
Skin corrosion/irritation
No data available
Serious eye damage/eye irritation
Respiratory or skin sensitisation
Germ cell mutagenicity
Carcinogenicity
4
IARC: No component of this product present at levels greater than or equal to 0.1% is identified as
probable, possible or confirmed human carcinogen by IARC.
ACGIH: No component of this product present at levels greater than or equal to 0.1% is identified as a
carcinogen or potential carcinogen by ACGIH.
NTP: No component of this product present at levels greater than or equal to 0.1% is identified as a
known or anticipated carcinogen by NTP.
OSHA: No component of this product present at levels greater than or equal to 0.1% is identified as a
carcinogen or potential carcinogen by OSHA.
Reproductive toxicity
Specific target organ toxicity -single exposure
No data available
Specific target organ toxicity -repeated exposure
Aspiration hazard
No data available
Additional Information
RTECS: Not available
To the best of our knowledge, the chemical, physical, and toxicological properties have not been thoroughly
investigated.
12.1 Toxicity
No data available
PBT/vPvB assessment not available as chemical safety assessment not required/not conducted
Product
Offer surplus and non-recyclable solutions to a licensed disposal company. Contact a licensed professional waste
disposal service to dispose of this material. Dissolve or mix the material with a combustible solvent and burn in a
chemical incinerator equipped with an afterburner and scrubber.
Contaminated packaging
Dispose of as unused product.
DOT (US)
UN number: 2735 Class: 8 Packing group: II
IMDG
UN number: 2735 Class: 8 Packing group: II EMS-No: F-A, S-B
5
Proper shipping name: AMINES, LIQUID, CORROSIVE, N.O.S. ([4-(trifluoromethyl)cyclohexyl]methanamine)
IATA
UN number: 2735 Class: 8 Packing group: II
reproductive harm.
HMIS Rating
Health hazard: 3
Flammability: 0
Physical Hazard 0
NFPA Rating
Health hazard: 3
Fire Hazard: 0
6
Reactivity Hazard: 0