Professional Documents
Culture Documents
BOQ of Vidyavihar 9.2m 28-02-23
BOQ of Vidyavihar 9.2m 28-02-23
Sr.No. Cost Head Item No. Range Estimated Cost (₹) weightage (%)
Notes
1. This Estimate is prepared on the basis of General arrangement drawings. Refer annexure A.
2. This estimate is for tender purpose only. The quantities may varry slightly depending upon site connditions and detailed design
WIDENING AND RECONSTRUCTION OF TWO CULVRTS OVER SOMAIYA NALLAH FROM VIDYAVIHAR STATION TO
TANSA MAINS IN CA - 310 IN "N" WARD
Bill of Quantities
2 R3-BW-1-02 Shifting and locating the drilling equipment from one Each unit 2.00 ₹ 2,705.00 ₹ 5,410.00
location to another within a lead of 500 m between
successive locations including surveying the spot for
establishing bore hole location, fixing ground levels
with reference to datum RLs and observing
groundwater level during boring operation etc.
complete as specified and directed.
R3-BW-1-03-a a) Depth upto 6.0m below ground surface Rmt 12.00 ₹ 1,500.00 ₹ 18,000.00
4 Taking trial bores for subsoil investigation through
rock using rotary drilling equipment with NX size
diamond core drilling bits and double tube core
barrel to obtain approximately 54 mm dia. rock
cores including provision of wooden boxes for storage
of cores, indexing the core samples at site of
work and conveying the same to the headquarters of
concerned office etc. complete as specified and
directed.
R3-BW-1-05-a a) Depth upto 10.0 m below ground surface Rmt 12.00 ₹ 1,800.00 ₹ 21,600.00
5 R3-BW-1-06 Conducting Standard penetration test as per Nos 2.00 ₹ 243.00 ₹ 486.00
specifications in soil at various levels of bore holes
and reporting the results in the approved format etc.
complete as specified and directed.
6 R3-BW-1-07-b Collecting disturbed samples of soil from bore Nos 2.00 ₹ 237.00 ₹ 474.00
holes as per specifications and delivering the same
to the testing laboratory anywhere in Greater
Mumbai as directed etc. complete as specified
and directed. -b) In polythene bags by driving 100 mm
size tube.
7 R3-BW-1-08 Collecting undisturbed samples of soil as per Nos 2.00 ₹ 551.00 ₹ 1,102.00
specifications at any depth in M.S. black tube 100
mm dia. 450 mm long, sealed at both ends with
paraffin wax and delivering the same to the testing
laboratory anywhere in Greater Mumbai etc. complete
as specified and directed.
8 R3-BW-1-19 Preparing and submitting reports and drawings in Nos 1.00 ₹ 23,729.00 ₹ 23,729.00
triplicate for location depth and details of underground
pipe lines, cables and services as existing according to
standard technique as specified upto whatever depth of
excavation and including all equipment, material, and
labour of technical expertise as directed excluding
excavation.
WIDENING AND RECONSTRUCTION OF TWO CULVRTS OVER SOMAIYA NALLAH FROM VIDYAVIHAR STATION TO
TANSA MAINS IN CA - 310 IN "N" WARD
Bill of Quantities
19 R3-RW-7-37 To carry out total station survey of the road with FHM 1.00 ₹ 20,182.00 ₹ 20,182.00
reference to existing co-ordinate system by
establishing control stations by establishing
temporary bench mark from permanent bench
mark, marking centre line of the road by nails,
carrying out detailed levelling, plotting cross sections
longitudinally at 20 mtr. intervals with levels at
every 4 mtr. cross distance, preparing drawings on
Auto cad to the scale of 1:500 and supplying 2 hard
copies and 1 soft copy in C.D. form. etc.
complete. Upto 18.3 mtr wide road.
22 R3-CS-EW-3 Excavation for foundations, substructures, basements, Cum 423.00 ₹ 644.00 ₹ 272,412.00
tanks, sumps, walls, chambers, manholes, trenches,
poles, pits & general building works in all types of
soils, vegetable earth, soft murum, running sand,
shingle, turf clay, loam, peat, ash, shale, slag, chalk,
garbage, muddy/ marshy/ slushy soil, marine clay,
reclaimed land etc. for depths/lifts upto 1.5M measured
from the ground level, including dressing/ trimming
the sides, leveling and ramming of bottoms, manual
dewatering, removing rank vegetation, backfilling in
layers not more than 200mm thickness, watering,
consolidating, compacting to achieve not less then 97%
Modified Proctor density conforming to relevant IS,
stacking the selected material in measurable heaps for
future use within owners space or disposing within an
initial lead of 150m as directed, loading, unloading,
leveling excluding shoring, strutting etc. complete as
directed by Engineer-in-Charge. Note: 1) The rate
includes the handling/supporting the existing utilities
such as cables, drains, pipes, water mains etc. 2) It also
includes the royalty and other taxes applicable if any.
For more details refer General Notes.
23 R3-CS-EW-2-a Extra over above item CS-EW-1 for lift from 1.5m to Cum 379.00 ₹ 735.00 ₹ 278,565.00
3.0m
24 R3-CS-EW-2-b Extra over above item CS-EW-1 for lift from 3.0m to Cum 224.00 ₹ 781.00 ₹ 174,944.00
4.5m
25 R3-SWD-153-A Constructing cofferdam of puddle bags with clay etc. Cum 149.00 ₹ 6,940.00 ₹ 1,034,060.00
as specified & as directed by Engineer in Charge.
WIDENING AND RECONSTRUCTION OF TWO CULVRTS OVER SOMAIYA NALLAH FROM VIDYAVIHAR STATION TO
TANSA MAINS IN CA - 310 IN "N" WARD
Bill of Quantities
27 R3-BW-3-8-b Providing and laying plain cement concrete in Cum 58.00 ₹ 7,596.00 ₹ 440,568.00
abutment and piers, head walls for culverts, using max
aggregate size of 40mm minimum cement content of
310Kg and max water cement ratio of 0.45 including
shuttering and scaffolding complete as specified and
directed. the rate including providing 100 dia PVC
Pipe weep holes at 1.5m c/c vertical and horizontal
above ground level wherever required ( The abutment
and piers shall be cast for only 1.0m height at a time)-
Walls
28 R3-BW-4-34-a Providing and placing in position controlled cement Cum 79.00 ₹ 8,540.00 ₹ 674,660.00
concrete of M-40 grade using minimum cement
content as 400Kg/cum and max water cement ratio of
0.40 for cast-in-situ portions after launching girders of
RCC Deck Slab, cross diaphragms to required lines
and levels including levelling, compacting by
vibrators, curing including formwork, temporary
supports as necessary and required etc.complete as
specified and directed but excluding
reinforcement.Height upto 5m
29 R3-BW-3-27 Providing and placing in position controlled cement Cum 105.00 ₹ 8,131.00 ₹ 853,755.00
concrete M-40 grade using minimum cement content
as 400Kg/cum and max water cement ratio of 0.40 for
RCC work in coping on wing walls, bedblocks,
abutment/pier/columncaps, dirtwalls ,pedestals for
bearing on piers/abutments as per drawing sand
designs including projections, moulding, champhers
etc. of required shape and size including levelling,
compacting by vibrators, curing, finishing the exposed
surfaces including formwork, shuttering and centering
as necessary and required etc. complete as specified
and directed but excluding reinforcement.
30 R3-BW-2-17 Providing and placing in position controlled cement Cum 36.00 ₹ 5,869.00 ₹ 211,284.00
concrete of M-15 grade for foundation work with
minimum cement 400 kg./cum. and water cement ratio
not exceeding 0.4 for PCC raft foundation slab with V
notches Sloped / flat / strlp footings, pile caps tie
beams to required lines / levels including leveling,
compacting by vibrators, curing including shuttering,
centering as necessary and required etc. complete as
specified and as directed
WIDENING AND RECONSTRUCTION OF TWO CULVRTS OVER SOMAIYA NALLAH FROM VIDYAVIHAR STATION TO
TANSA MAINS IN CA - 310 IN "N" WARD
Bill of Quantities
32 R3-RW-1-08 P/L earth work in embankments &/ filling low-lying Cum 501.00 ₹ 1,237.00 ₹ 619,737.00
grounds in layers not exceeding 25 cm in loose
thickness & compacting each layer with a 10/12 tonnes
power roller including levelling watering etc. complete
in conformity with the required lines, grades & cross
sections (Lab C.B.R. in soaked conditions shall not be
less than 4) etc. including cleaning & grubbing the
ground (The contractor should take note of the site
conditions pertaining to creek lands under reference &
should note that nothing extra whatsoever will be paid
like diversion of water, the protective measures that
may be necessary to be carried out to protect the
embankment from water & settlement of earth.)
Settlements will not be paid for the earth work and
must be retained for consolidations for one season &
settlement if any shall be ascertained & made up free
of cost. The rate includes efforts for diversion of water,
protection of embankments & also settlement of
earth.etc. complete as per prevailing MCGM
specifications for Roadworks clause no. 151.0
33 R3-RW-2-21 Providing & laying, spreading & compacting specified Cum 66.00 ₹ 2,702.00 ₹ 178,332.00
crushed stone in granular subbase course including
premixing the material in mechanical mixer (pug mill
or approved type), spreading of mixed material in
uniform layer of 100 mm to 75 mm (compacted
thickness each) with motor grader or paver on prepared
murum surface & compacting with 10 tonne vibratory
roller to achieve desired density including all material,
labour, machinery, lighting, barricading to all lifts &
lead, maintenance of diversion etc. complete (metal
gradation from 75mm to 75 micron as per prevailing
MCGM specifications for Roadworks clause no.210).
WIDENING AND RECONSTRUCTION OF TWO CULVRTS OVER SOMAIYA NALLAH FROM VIDYAVIHAR STATION TO
TANSA MAINS IN CA - 310 IN "N" WARD
Bill of Quantities
35 R3-RW-10-01 Providing & laying M-40 cement concrete having avg. Cum 124.00 ₹ 5,928.00 ₹ 735,072.00
compressive strength 45 Mpa, flextural strength 4.8
Mpa including form work, mixing in non-tilting
mechanical mixer (with Weigh Batcher), compacting
by internal & surface vibrator, finishing, curing &
tarring the sides of slabs with hot bitumen/ black Japan
Paint as specified and as directed (cement mortar vata
will be paid separtely). Contractors have to make their
own arrangement for potable water for construction/
curing, etc. & will be not paid separately.
36 R3-RW-10-06 Providing & laying R.C.C. running beam in M-40 Cum 63.00 ₹ 901.00 ₹ 56,763.00
cement concrete including required formwork mixing,
compacting & curing, etc. complete reinforced with
12mm dia.(Minimum 4 Nos.)M.S. main bars & 6mm
Dia M.S. rings at 15cm/c/c to be anchored in slipper
slab properly with M.S. reinforcement as per drawing
etc. complete as specified(Steel will not be paid
separately).Contractor has to make his own
arrangement for portable waterfor construction/curing
with hessian cloth, etc. & will not be paid separately.
37 R3-RW-10-12 Providing & fixing in position mild steel tie bars of MT 1.00 ₹ 70,944.00 ₹ 70,944.00
12mm dia 55cm long & 45cm C/C whenever directed
including handling , wrapping with paper for half
length, fixing, straightening, wastage etc. complete in
all respect as directed.
38 R3-RW-10-13 Providing & fixing in position M.S. dowel bars of MT 3.00 ₹ 99,657.00 ₹ 298,971.00
32mm dia 55cm long & 30cm C/C whenever directed
including handling, fixing, etc. complete (no extra
payment will be made for applying bitumen & grease
to dowel bars)
39 R3-RW-10-11 Providing & fixing high density polythene pipe of Each 293.00 ₹ 31.00 ₹ 9,083.00
approved quality to fit around the dowel bars of 32mm
dia at the end of expansion joints, fully greased inside,
cotton waste in the pipe around the dowel bars & the
pipe duly capped at the end as directed. (H.D.P. pipe
shall be 30cm in length). As shown in the drawing.
WIDENING AND RECONSTRUCTION OF TWO CULVRTS OVER SOMAIYA NALLAH FROM VIDYAVIHAR STATION TO
TANSA MAINS IN CA - 310 IN "N" WARD
Bill of Quantities
41 R3-RW-10-07 Cutting of construction & dummy joints of M-35 Rmt 439.00 ₹ 84.00 ₹ 36,876.00
C.C.& above slab by mechanical means within 10 to
16 hrs of casting of bay/ slab as directed. A) transverse
dummy joints 100 mm deep or 1/3 thickness of
concrete pavement & 6 mm wide.
42 R3-RW-10-08 Cutting of construction & dummy joints of M-35 Rmt 439.00 ₹ 84.00 ₹ 36,876.00
C.C.& above slab by mechanical means within 10 to
16 hrs of casting of bay/ slab as directed. B)
Longitudinal construction joints 100mm deep or 1/3rd
thickness of slab & 6 mm wide
43 R3-RW-10-19 Dressing of M-35 & above new C.C.pavement, Rmt 439.00 ₹ 108.00 ₹ 47,412.00
dummy, transverse, longitudinal & expansion joints
with hot rubberised sealing compound confirming to IS
1834-1984 after proper cleaning with compressed air,
applying required primer & providing a layer of lime
powder over hot sealing compound etc. complete as
directed. A) Sealing 6mm wide dummy/ transverse
joints with a depth of 100mm or 1/3rd thickness of
concrete pavement.
44 R3-RW-10-20 Dressing of M-35 & above new C.C. pavement, Rmt 439.00 ₹ 108.00 ₹ 47,412.00
dummy, transverse, longitudinal & expansion joints
with hot rubberised sealing compound conforming to
IS 1834-1984 after proper cleaning with compressed
air, applying required primer & providing a layer of
lime powder over hot sealing compound etc. complete
as directed. B) Sealing of 6mm wide longitudinal joint
with depth of 100mm or 1/3rd thickness of concrete
pavement.
45 R3-RW-10-10 Providing & placing 5mm thick thermocol in dummy Sqm 4.00 ₹ 88.00 ₹ 352.00
& construction joints immediately after cutting of
joints & removing the same before dressing of dummy
& construction joints etc. complete, as directed.
46 R3-RW-10-15 Providing & constructing cement vatas in c/m 1:10 at Sqm 439.00 ₹ 75.00 ₹ 32,925.00
0.6mx0.6m c/c admeasuring 0.09m at bottom, 0.04m at
top & 0.075m deep & maintaining the same throughout
14 days curing & removing the same thereafter, as
directed.
47 R3-RW-5-21 Providing and applying PRIME COAT with Sqm 105.00 ₹ 101.00 ₹ 10,605.00
CATIONIC BITUMEN EMULSION (SS) @ 12 to 15
Kg. of 10Sqmt over prepared surface to receive
bituminous mix by applying PRIMER with mechanical
spray bitumen, including cleaning of road surface etc.
completed, as directed for Low Porosity surface & the
primed surface shall be allowed to cure for at least 24
hours or any other higher period, as is found to be
necessary to allow all the moisture or volatiles to
evaporate before any subsequent bituminous surface
treatment or mix is laid (As per prevailing MCGM
specifications for Roadworks Clause No. 313, curing
as per 313.5)
WIDENING AND RECONSTRUCTION OF TWO CULVRTS OVER SOMAIYA NALLAH FROM VIDYAVIHAR STATION TO
TANSA MAINS IN CA - 310 IN "N" WARD
Bill of Quantities
49 R3-RW-5-22 Providing and applying TACK COAT with Sqm 208.00 ₹ 39.00 ₹ 8,112.00
CATIONIC BITUMEN EMULSION (RS) @ 0.2
to0.25 Kg. of Sq.mt. over prepared surface to receive
bituminous mix by applying TACK COATwith
mechanical spray bitumen, includingcleaning of road
surface etc. completed, asdirected For NORMAL
BITUMINOUS SURFACES& the tack coat shall be
left to cure until all the construction is started, which is
indicated by
change in colour from brown to black (As
perprevailing MCGM specification for
RoadworkClause No. 314, curing as per 314.3.4)
50 R3-RW-5-47 P/L hot Premix Dense bituminous macadam with Cum 7.00 ₹ 15,497.00 ₹ 108,479.00
4.50% bitumen content of grade VG-40 to the required
line, level and camber rolling with 10/12 M.T.power,
vibratory roller & sensor paver etc. complete as
specified and as directed to thickness of 75 mm. with
antistripping agent at 1% by weight of bitumen using
grading II of "MORTH"( As per prevailing MCGM
specifications for Roadworks clause no.354)
51 R3-RW-5-30 P/L mastic Asphalt 25mm thick having bitumen Sqm 129.00 ₹ 1,439.00 ₹ 185,631.00
content 10% by weight as per I.S. code No.5317/2002.
(As per prevailing MCGMspecification for Roadwork
Clause No. 365)
WIDENING AND RECONSTRUCTION OF TWO CULVRTS OVER SOMAIYA NALLAH FROM VIDYAVIHAR STATION TO
TANSA MAINS IN CA - 310 IN "N" WARD
Bill of Quantities
53 R3-CS-EW-10 Dewatering the excavated trenches/pits, pools of water, Hr 1420.00 ₹ 104.00 ₹ 147,680.00
well works by using pumps and other devices
including disposing off water to safe distance as
directed by Engineer-in-charge including cost of
machinery, labour, fuel, pipe and it's accessories etc.
complete. Note : This item will be operated/executed
with the prior specific sanction of the Head of
department
54 R3-CS-CW-35-c Providing and fixing in position steel bars MT 63.00 ₹ 80,080.00 ₹ 5,045,040.00
reinforcement of various diameters for R.C.C. pile, pile
caps, footings,raft,retaining wall,shear wall, lift wall,
foundations, slabs, beams, columns, canopies,
staircases, newels, chajjas, lintels, pardies, coping, fins,
arches, etc. as per detailed designs, drawings and bar
bending schedules,including straightening, cutting,
bending, hooking the bars, binding with wires or tack
welding, supporting as required etc. all complete at all
levels.
55 R3-BW-5-8 providing Fusion Bonded epoxy coating (FBEC) to MT 63.00 ₹ 13,682.00 ₹ 861,966.00
reinforcing steel bars as per IS 13620-1993
specifications for coating thickness of 175 microns
(with permissible variation of 50 microns) including
testing at plants etc. complete as per specifications.
56 R3-BW-5-1-j Providing and fixing in position Drainage Spouts Nos 4.00 ₹ 2,224.00 ₹ 8,896.00
including trough of 260 x 260. size fabricatede using
mild steel plates, flats, MS grating, etc. and 100mm dia
GI pipe 1 m long as per detailed drawings etc.
complete as specified and directed.
WIDENING AND RECONSTRUCTION OF TWO CULVRTS OVER SOMAIYA NALLAH FROM VIDYAVIHAR STATION TO
TANSA MAINS IN CA - 310 IN "N" WARD
Bill of Quantities
58 R3-BW-5-7-i Providing and applying hot applied thermoplastic road Sqm 48.00 ₹ 1,011.00 ₹ 48,528.00
marking material with glass beads extremely high skid
resistance 2.5 mm thick without primer coat (Tack
coat) on Asphalt road surface. All labour, materials,
with special aggregates as specified in B.S. part - l & ll
1989 and carrying out the marking on any road in
center line and other marking continious or intermitten
10cm. or 15cm width also pedestrians crossing strips as
well as spraying further quantity of glass beads of type
ll uniformly into a mono layer on to the hot paint line
in quick succession of the paint spraying opration @
250gms per sqm. area as directed and as per BS /
MOST specifications in white / yellow colour.
59 R3-RT-16-24 Providing, Fabricating, Erecting on site Cautionary Nos 2.00 ₹ 17,030.00 ₹ 34,060.00
Boards as per Cautionary Sign Drawing No C2,
Vertical poles shall be Hot dip galvanised pipe of 65
NB, 3mm Wall thickness. Signage plaque (box) shall
be of size 900mm triangle. The box shall be pasted
with MICRO PRISMATIC GRADE retro reflective
base sheets on both sides conforming to Type XI
standards of I.R.C. 67 2012 CODE. Letters or borders
to be pasted on this box using transparent electro
cuttable film/Screen Printing. The reflectivity of sheet
shall have warranty of10years. The reflection count
shall not be less than 80% of its original reflection
after10years. The vertical pipe shall be fixed to the
ground by means of properly designed foundation of
size 600mmx600mmx600mm below ground &
450mmx450mmx200mm above ground. Complete as
per the specification and directed by the Engineer In
Charge.
WIDENING AND RECONSTRUCTION OF TWO CULVRTS OVER SOMAIYA NALLAH FROM VIDYAVIHAR STATION TO
TANSA MAINS IN CA - 310 IN "N" WARD
Bill of Quantities
61 R3-BW-5-3-f Providing and applying protective paint consisting of sqm 105.00 ₹ 284.00 ₹ 29,820.00
two coats of coal tar epoxy paint over one coat of
primer of approved quality and make to the external
surfaces of concrete structures to be buried under the
soil etc. complete as specified and directed.
62 R3-CS-PN-5 Providing and applying first single coat of approved Sqm 105.00 ₹ 147.00 ₹ 15,435.00
primer and two coats of acrylic plastic emulsion paint
of an approved make and colour as per manufacturers
specifications to any surface, at all height and locations
as directed including scaffolding, cleaning and
preparing surfaces for painting by any approved means
etc. complete as directed by Engineer-in-charge.
63 R3-BW-4-51 Providing and placing in position controlled cement Rmt 156.00 ₹ 2,660.00 ₹ 414,960.00
concrete of M-30 grade using minimum cement
content as 400Kg/cum and max water cement ratio of
0.40 in cast-in-situ Anti Crash Barrier with form
finished surface as per detailed drawings to required
line and levels including compacting by vibrators,
levelling, formwork, curing and finishing etc.,
providing temporary supports as required including
provisions for fixing sockets for lighting posts at a
distance of 20 mtrs. centre to centre as directed and
providing and fixing 100mm PVC pipes inside
throughout the length for passing electric cables
complete as specified and directed as per drawings and
design (Excluding reinforcement).
WIDENING AND RECONSTRUCTION OF TWO CULVRTS OVER SOMAIYA NALLAH FROM VIDYAVIHAR STATION TO
TANSA MAINS IN CA - 310 IN "N" WARD
Bill of Quantities
66 R3-BW-8-50 RATE ANALYSIS FOR STEEL PLATE GIRDER MT 18.00 ₹ 198,920.00 ₹ 3,580,560.00
FABRICATION & ERECTIONProviding, detailing,
fabricating and fixing at desired location using hot
rolled sections and M S Plates of high grade steel as
per specifications and approved fabrication drawings
(which are to be prepared by Contractor and got
approved from Engineer), transporting to site and
erecting/launching structural steel members/girders for
all heights & at all levels including provision of
necessary erection/launching acsessaries and
machinary for erection/launching, bolts, fixing bolts,
nuts, washers, cleats, stiffeners, gussets, baseplate and
all necessary fixtures and operations like preheating as
per specifications, straightening, bending, cutting,
drilling, grinding, machining if specified, welding,
grinding and removing the welding burr and preparing
surface for painting with Sand blasting, metalizing and
painting of loose fabricated components and girders
with sprayed aluminium followed by protective coating
of painting outside running line complete with
contractor's own paint, other material, labour,
scaffolding, consumable. Note: The protective coating
of paint shall be as follows:(i) First coat of Each primer
to IS:5666. (ii) One coat of Zinc Chromate primer to
IS: 104 and two coats of aluminium paint to IS:2339.
Total Thickness will be not less than 200 micron.
Guarantee period will be 5 years including touching up
with spray painting after erection etc complete as
directed by Engineer In Charge. E-350 Grade Steel
67 R3-BW-5-7-k Providing, fitting and fixing mild Steel railing Rmt 54.00 ₹ 3,662.00 ₹ 197,748.00
complete as per drawing and Technical Specification
WIDENING AND RECONSTRUCTION OF TWO CULVRTS OVER SOMAIYA NALLAH FROM VIDYAVIHAR STATION TO
TANSA MAINS IN CA - 310 IN "N" WARD
Bill of Quantities
69 R2-CS-DD-5-a Demolishing stone rubble masonry manually/ by Cum 159.00 ₹ 1,677.00 ₹ 266,643.00
mechanical means including stacking of serviceable
material and disposal of unserviceable material within
50 metres lead as per direction of Engineer-in-charge
71 R3-CS-DD-2 Demolishing R.C.C. slab, R.C.C. wall of any Cum 443.00 ₹ 2,491.00 ₹ 1,103,513.00
thickness, R.C.C. beams, joists, R.C.C. columns, piles,
pile caps etc., in any thickness and size manually/ by
mechanical means including stacking of steel bars and
disposal of unserviceable material within 50 metres
lead as per direction of Engineer - in- charge.
72 R3-RW-7-21 Cutting down of tree having diameter above 150 mm & Each 4.00 ₹ 4,117.00 ₹ 16,468.00
Upto 300 mm
73 R3-RW-3-22 Removing the paver blocks of any thickness, size & SQM 83.00 ₹ 193.00 ₹ 16,019.00
colour from carriage way or footpath & transporting
the same to ward depot or any where in BMC limit.
The paver blocks shall be stacked neatly at specified
locations etc. complete as specified and as directed by
the Engineer.
74 R3-SWD-45 Supplying and providing blue trap stones of approved Cum 28.00 ₹ 2,469.00 ₹ 69,132.00
quality and laying hand set dry rubble packing 25 cm.
thick to required level and grade, camber including
filling in the interstices with 60 mm. metal and small
stone chips, etc. and thoroughly rammed, consolidated,
etc.as specified & as directed by Engineer in Charge.
75 R3-SWD-15-A Providing and laying RMC (Ready Mixed Concrete) Cum 11.00 ₹ 6,002.00 ₹ 66,022.00
M-15 grade Plain cement concrete in foundation
including boxing,curing by any means, etc. complete as
specified and/or as directed by Engineer in Charge.
76 R3-SE-2-9 Providing & laying M 20 c.c. For foundation/bedding Cum 100.00 ₹ 8,199.00 ₹ 819,900.00
including boxing, curing etc. complete as specified and
as directed.
77 R3-SE-2-14 Providing M 20 R.C.C. Work in dhapas, beams and Cum 100.00 ₹ 13,901.00 ₹ 1,390,100.00
slabs etc. with standard reinforcement of 1% including
centering etc. and finished smooth the exposed surface
with cement sand plaster 12 mm thick in the proportion
1:2 as directed.
78 R3-SE-4-10 Providing 20 mm thick with approved water proofing Sqm 33.00 ₹ 476.00 ₹ 15,708.00
compound in a proportion as specified by the
manufacturers per bag of cement.
WIDENING AND RECONSTRUCTION OF TWO CULVRTS OVER SOMAIYA NALLAH FROM VIDYAVIHAR STATION TO
TANSA MAINS IN CA - 310 IN "N" WARD
Bill of Quantities
80 R3-RW-7-47 Supplying and fixing 900 mm x 900 mm clear opening Nos 7.00 ₹ 8,961.00 ₹ 62,727.00
composite resin manhole cover with two cover design
of approved brand with 12.5 ton load capacity, as per
EN-124 standard. Covers & frame shall have SS Nut
bolt locking arrangement and top abrasion resistant
layer of decorative granite finish. Abrasion resistance
shall be conforming to IS15658:2006 and permissible
permanent set value of 6mm for each cover, after
application of 2/3 test load in five continuous
applications as per EN-124. The testing shall be
performed in fully equipped and NABL certified test
lab with random batch test (2% of lot size) as per
testing procedure stated in EN-124 standard, including
testing, inspection of material sample and finished
product in presence of Engineers (2nos.) at
Manufacturer's work place, etc. complete as specified
and as directed by Engineer-in Charge. (Inspection
shall be as per guidelines of EN-124-2015 standard
specifications.)
81 R3-RW-8-02 P/L 250 mm dia. R.C.C. hume pipes, NP2 class, Rmt 5.00 ₹ 868.00 ₹ 4,340.00
jointing, filling in 1:1 cement mortar, including
plugging of both the ends with gunny bags, brick
masonry in cement mortar 1:4 with plaster in cement
mortar 1: & curing etc. complete, as specified as
directed.
82 R3-SWD-142 Constructing single water entrance of internal size EA 10.00 ₹ 10,918.00 ₹ 109,180.00
0.50m x 0.60m with cast-in-situ coping in M-20 grade,
fixing of grating in M -20 as per standard drawings
(Dwg No. MCGM/SWD/2013-14), etc complete as
specified and as directed by Engineer in Charge.
(excluding excavation, providing and fixing of gratings
and frame)
83 R3-RW-3-41 Providing and fixing of cement concrete Kerb Stone of Rmt 100.00 ₹ 1,950.00 ₹ 195,000.00
various grades of size: 500mm width x 325 height x
165mm thick (Half Batter, Bull Nose/ Full Batter)
manufactured in wet press vacuum dewatering
technology plant / equivalant with face pimple finish
for high visibility with excellent quality and finish and
edges perfect and sharp. Grade – M-25 including
excavation in any soil except rock, laying a leveling
course of M 15 grade RMC 100mm thick to required
slope (inclusive of form work), jointing in C.M. 1:2
proportion flush to concrete surface, painting exposed
surface with one coat of primer and two coats of 1st
grade road marking paint in the yellow/ white/ black or
any shade as directed. (Kerbstones shall be procured
from MCGM registered agencies).
WIDENING AND RECONSTRUCTION OF TWO CULVRTS OVER SOMAIYA NALLAH FROM VIDYAVIHAR STATION TO
TANSA MAINS IN CA - 310 IN "N" WARD
Bill of Quantities
85 R3-SE-14-5 Providing, Laying and Jointing of 160mm dia (OD) Rmt 55.00 ₹ 28,740.00 ₹ 1,580,700.00
HDPE pipe (PN 6 Class-PE 80 grade: IS 14333) to
correct grade and alingnment upto 2.1 m depth
including boring, Pilot inclined dilling from exisitng
ground level upto required depth (invert level) on rig
side of proposed gravity sewer line (i.e. entry side)
using Horizontal Directional Drilling method in any
type of ground including soft soil, mixed ground and
soft/hard rock. Length of gravity sewer line i.e. actual
pipe laid will be considered for measurement.
Total ₹ 24,578,652.00
WIDENING AND RECONSTRUCTION OF TWO CULVRTS OVER SOMAIYA NALLAH FROM VIDYAVIHAR
STATION TO TANSA MAINS IN CA - 310 IN "N" WARD
Measurement Sheet for Testing & Engineering Surveys
Total
Sr. No. Item No. Description Unit Nos. Length Width Depth Quantity
Quantity
1 R3-BW-1-01 Providing and transporting necessary and adequate plant and equipment to site with in a
lead of 50 km for taking trial bores for subsoil investigations including conducting an
initial survey for establishing datum RLS and locations at trial bores including
installation of the drilling equipment of the first bore location etc. complete as specified
and directed
1 1.00
Each unit
1.00 1.00
2 R3-BW-1-02 Shifting and locating the drilling equipment from one location to another within a lead of
500 m between successive locations including surveying the spot for establishing bore
hole location, fixing ground levels with reference to datum RLs and observing
groundwater level during boring operation etc. complete as specified and directed.
2 2.00
Each shift
2.00 2.00
Taking trial bores upto 150 mm dia. for subsoil investigation through overburden and
soil of all sorts including providing of temporary casing and cleaning the bottom
of holes before conducting field tests or collecting samples at various depths etc.
complete as specified and directed.
12.00 12.00
Taking trial bores for subsoil investigation through rock using rotary drilling equipment
with NX size diamond core drilling bits and double tube core barrel to obtain
approximately 54 mm dia. rock cores including provision of wooden boxes for storage of
cores, indexing the core samples at site of work and conveying the same to
the headquarters of concerned office etc. complete as specified and directed.
Nos 2 2.00
2.00 2.00
6 R3-BW-1- Collecting disturbed samples of soil from bore holes as per specifications and
07-b delivering the same to the testing laboratory anywhere in Greater Mumbai as
directed etc. complete as specified and directed. -b) In polythene bags by driving
100 mm size tube.
Nos 2 2.00
2.00 2.00
7 R3-BW-1-08 Collecting undisturbed samples of soil as per specifications at any depth in M.S.
black tube 100 mm dia. 450 mm long, sealed at both ends with paraffin wax and
delivering the same to the testing laboratory anywhere in Greater Mumbai etc. complete
as specified and directed.
WIDENING AND RECONSTRUCTION OF TWO CULVRTS OVER SOMAIYA NALLAH FROM VIDYAVIHAR
STATION TO TANSA MAINS IN CA - 310 IN "N" WARD
Measurement Sheet for Testing & Engineering Surveys
Total
Sr. No. Item No. Description Unit Nos. Length Width Depth Quantity
Quantity
Nos 2 2.00
2.00 2.00
8 R3-BW-1-19 Preparing and submitting reports and drawings in triplicate for location depth and details
of underground pipe lines, cables and services as existing according to standard technique
as specified upto whatever depth of excavation and including all equipment, material, and
labour of technical expertise as directed excluding excavation.
Nos 1 1.00
1.00 1.00
Carrying out tests as per specifications for determination of:
9 R3-BW-1- i) Natural Nos 2 2.00 2.00
21-a moisture Content
(NMC) of soil
by Oven Drying
ii) Atterberg
method
limits
10 R3-BW-1- 2 2.00 2.00
21-b a) Liquid limit Nos
11 R3-BW-1- 2 2.00 2.00
21-c b) Plastic limit Nos
12 R3-BW-1- 2 2.00 2.00
21-d c) Shrinkage limit Nos
iii) Grain size
analysis including
grain size
distribution
curves in
accordance with
IS 2720 (part 4)
13 R3-BW-1- 2 2.00 2.00
21-e a) Sieve Analysis Nos
14 R3-BW-1- 2 2.00 2.00
21-f b) Hydrometer
Analysis Nos
15 R3-BW-1- 2 2.00 2.00
21-g iv) In-situ density
of soil samples Nos
16 R3-BW-1- v) Specific 2 2.00 2.00
21-h gravity Nos
17 R3-BW-1- Nos 2 2.00 2.00
21-i vi) Unconfined
compressive
strength of rock
samples,
including
determination of
percentage of
water absorption
and density.
18 R3-BW-1-28 Conducting Unconfined compression test on undisturebed soil samples or soil samples
compacted to specified density in accordance with IS : 2720 (part 10) and reporting results
thereof as per prescribed Proforma etc. complete as specified and directed.
Nos 2 2.00
2.00 2.00
WIDENING AND RECONSTRUCTION OF TWO CULVRTS OVER SOMAIYA NALLAH FROM VIDYAVIHAR
STATION TO TANSA MAINS IN CA - 310 IN "N" WARD
Measurement Sheet for Testing & Engineering Surveys
Total
Sr. No. Item No. Description Unit Nos. Length Width Depth Quantity
Quantity
19 R3-RW-7-37 To carry out total station survey of the road with reference to existing co-ordinate system
by establishing control stations by establishing temporary bench mark from
permanent bench mark, marking centre line of the road by nails, carrying out detailed
levelling, plotting cross sections longitudinally at 20 mtr. intervals with levels at
every 4 mtr. cross distance, preparing drawings on Auto cad to the scale of 1:500 and
supplying 2 hard copies and 1 soft copy in C.D. form. etc. complete. Upto 18.3 mtr
wide road.
Total
Sr. No. Item No. Description Unit Nos. Length Width Depth Quantity
Quantity
21 R3-CS-EW-16 Excavation over areas for basements, roads, land/plot developement in soft/ disintegrated
rock, sand stone, stiff clay, gravel, cobblestone, hard laterite, water bound macadam, wet
mix macadam, pitching, soling, paths and hardcore, lime concrete, plain cement concrete,
stone masonry and all types of brick/ block masonry below ground level, rock boulders,
etc. for all depths/lifts including manual dewatering, filling the selected excavated earth at
the locations as directed, in layers not more than 200mm thickness, watering,
consolidating, compacting to achieve not less then 97% Modified Proctor density
conforming to relevant IS, stacking the selected material in measurable heaps for future
use within owners space or disposing within an initial lead of 150m as directed, loading,
unloading, leveling excluding shoring, strutting etc. complete as directed by Engineer-in-
Charge. Note: 1) The rate includes the handling/supporting the existing utilities such as
cables, drains, pipes, water mains etc. 2) It also includes the royalty and other taxes if
any.
Breaking of
Existing Road
2 Cum 1 45.00 8.50 0.30 114.75
Breaking of
Existing Road
2 Cum 1 12.00 8.50 0.30 30.60
146.00 161.00
22 R3-CS-EW-3 Excavation for foundations, substructures, basements, tanks, sumps, walls, chambers,
manholes, trenches, poles, pits & general building works in all types of soils, vegetable
earth, soft murum, running sand, shingle, turf clay, loam, peat, ash, shale, slag, chalk,
garbage, muddy/ marshy/ slushy soil, marine clay, reclaimed land etc. for depths/lifts
upto 1.5M measured from the ground level, including dressing/ trimming the sides,
leveling and ramming of bottoms, manual dewatering, removing rank vegetation,
backfilling in layers not more than 200mm thickness, watering, consolidating,
compacting to achieve not less then 97% Modified Proctor density conforming to relevant
IS, stacking the selected material in measurable heaps for future use within owners space
or disposing within an initial lead of 150m as directed, loading, unloading, leveling
excluding shoring, strutting etc. complete as directed by Engineer-in-Charge. Note: 1)
The rate includes the handling/supporting the existing utilities such as cables, drains,
pipes, water mains etc. 2) It also includes the royalty and other taxes applicable if any.
For more details refer General Notes.
Upto 1.5m
Excavation of
Nalla Cum 1 10.50 9.00 1.50 141.75 156.00
Excavation of
outside nalla
portion Cum 1 30.00 4.06 1.50 182.70 201.00
Foundation for
Temproray
bridge Cum 2 20.00 1.50 60.00 66.00
23 R3-CS-EW-2-a From 1.5m to
3m
Excavation of
Nalla Cum 1 10.50 9.00 1.50 141.75 156.00
WIDENING AND RECONSTRUCTION OF TWO CULVRTS OVER SOMAIYA NALLAH FROM VIDYAVIHAR
STATION TO TANSA MAINS IN CA - 310 IN "N" WARD
Total
Sr. No. Item No. Description Unit Nos. Length Width Depth Quantity
Quantity
Excavation of
outside nalla
portion Cum 1 30.00 4.06 1.50 182.70 201.00
Foundation for
Temproray
bridge Cum 2 20.00 0.50 20.00 22.00
24
R3-CS-EW-2-b From 3m to
4.5m
Excavation of
outside nalla
portion Cum 1 9.20 8.88 0.25 20.42 23.00
Breaking of
outside nalla
portion Cum 1 30.00 4.06 1.50 182.70 201.00
25 R3-SWD-153-A Constructing cofferdam of puddle bags with clay etc. as specified & as directed by
Engineer in Charge.
Cum 2 9.00 3.00 2.50 135.00
135.00 149.00
26 R3-BW-2-25 Providing and placing in position controlled cement concrete of M-40 grade for
foundation work with minimum cement 400 kg./cum. and water cement ratio not
exceeding 0.4 for RCC raft foundation slab with V notches Sloped / flat / strlp footings,
pile caps tie beams to required lines / levels including leveling, compacting by vibrators,
curing including shuttering, centering as necessary and required etc. complete as specified
and as directed but excluding reinforcement.
Total
Sr. No. Item No. Description Unit Nos. Length Width Depth Quantity
Quantity
29 R3-BW-3-27 Providing and placing in position controlled cement concrete M-40 grade using minimum
cement content as 400Kg/cum and max water cement ratio of 0.40 for RCC work in
coping on wing walls, bedblocks, abutment/pier/columncaps, dirtwalls ,pedestals for
bearing on piers/abutments as per drawing sand designs including projections, moulding,
champhers etc. of required shape and size including levelling, compacting by vibrators,
curing, finishing the exposed surfaces including formwork, shuttering and centering as
necessary and required etc. complete as specified and directed but excluding
reinforcement.
Pcc(below box
structure) Cum 1 13.70 9.20 0.15 18.91
19.00 21.00
Pcc(below
Rcc wall) Cum 2 2.80 3.00 0.15 2.52
3.00 4.00
Pcc(below
Rcc wall) Cum 2 10.20 3.00 0.15 9.18
10.00 11.00
31 R3-BW-2-13 Providing and laying Dry Rubble stone packing having thickness 230 mm and above in
foundation including hand packing in regular line and level, filling interstices with small
pieces of stone, thoroughly ramming and consolidating including watering as necessary
etc. complete as specified and directed
Soling (below
box structure) Cum 2 13.45 9.20 0.23 56.92
57.00 63.00
Soling (below
Rcc wall) Cum 4 2.80 3.00 0.23 7.73
8.00 9.00
Soling (below
Rcc wall) Cum 4 10.20 3.00 0.23 28.15
29.00 32.00
WIDENING AND RECONSTRUCTION OF TWO CULVRTS OVER SOMAIYA NALLAH FROM VIDYAVIHAR
STATION TO TANSA MAINS IN CA - 310 IN "N" WARD
Descriptio
Sr. No. Item No. Unit Nos. Length Width Depth Quantity Total Quantity
n
32 R3-RW-1- P/L earth work in embankments &/ filling low-lying grounds in layers not exceeding
06 25 cm in loose thickness & compacting each layer with a 10/12 tonnes power roller
including levelling watering etc. complete in conformity with the required lines, grades
& cross sections (Lab C.B.R. in soaked conditions shall not be less than 4) etc.
including cleaning & grubbing the ground (The contractor should take note of the site
conditions pertaining to creek lands under reference & should note that nothing extra
whatsoever will be paid like diversion of water, the protective measures that may be
necessary to be carried out to protect the embankment from water & settlement of
earth.) Settlements will not be paid for the earth work and must be retained for
consolidations for one season & settlement if any shall be ascertained & made up free
of cost. The rate includes efforts for diversion of water, protection of embankments &
also settlement of earth.etc. complete as per prevailing MCGM specifications for
Roadworks clause no. 151.0
Descriptio
Sr. No. Item No. Unit Nos. Length Width Depth Quantity Total Quantity
n
35 R3-RW- Providing & laying M-40 cement concrete having avg. compressive strength 45 Mpa,
10-01 flextural strength 4.8 Mpa including form work, mixing in non-tilting mechanical
mixer (with Weigh Batcher), compacting by internal & surface vibrator, finishing,
curing & tarring the sides of slabs with hot bitumen/ black Japan Paint as specified and
as directed (cement mortar vata will be paid separtely). Contractors have to make their
own arrangement for potable water for construction/ curing, etc. & will be not paid
separately.
Each 56 56.00
Each 210 210.00
266.00 293.00
40 R3-RW- Providing & laying waterproof paper of 40 GSM including overlap ( to be not less than
10-14 10cm) etc. complete as specified as directed.
Sqm 1 12.00 7.00 84.00
Sqm 1 45.00 7.00 315.00
399.00 439.00
41 R3-RW- Cutting of construction & dummy joints of M-35 C.C.& above slab by mechanical
10-07 means within 10 to 16 hrs of casting of bay/ slab as directed. A) transverse dummy
joints 100 mm deep or 1/3 thickness of concrete pavement & 6 mm wide.
WIDENING AND RECONSTRUCTION OF TWO CULVRTS OVER SOMAIYA NALLAH FROM VIDYAVIHAR
STATION TO TANSA MAINS IN CA - 310 IN "N" WARD
Descriptio
Sr. No. Item No. Unit Nos. Length Width Depth Quantity Total Quantity
n
Rmt 1 84.00 84.00
Rmt 1 315.00 315.00
399.00 439.00
42 R3-RW- Cutting of construction & dummy joints of M-35 C.C.& above slab by mechanical
10-08 means within 10 to 16 hrs of casting of bay/ slab as directed. B) Longitudinal
construction joints 100mm deep or 1/3rd thickness of slab & 6 mm wide
Descriptio
Sr. No. Item No. Unit Nos. Length Width Depth Quantity Total Quantity
n
95.00 105.00
48 R3-BW-5- Mastic Asphalt (Providing and laying 12 mm thick mastic asphalt wearing course on
2-a top of deck slab excluding prime coat with paving grade bitumen meeting the
requirements given in table 500- 29, prepared by using mastic cooker and laid to
required level and slope after cleaning the surface, including providing antiskid surface
with bitumen precoated fine grained hard stone chipping of 9.5 mm nominal size at the
rate of 0.005cum per 10qm and at an approximate spacing of 10 cm center to center in
both directions, pressed into surface when the temperature of surfaces not less than 100
deg. C, protruding 1 mm to 4 mm over mastic surface, all complete .)
Total
Sr. No. Item No. Description Unit Nos. Length Width Depth Quantity
Quantity
R3-SWD-233 Desilting and cleaning of nallas / storm water drains of all types including the
underground, closed as well as open and of all sizes & shapes including pumping out the
liquid waste / sewerage / storm water and/or mechanical means such as deploying J.C.B.,
Poclain, Pontoon mounted poclain, truxor, silt pusher, or any other type of machine and
spreading around / stacking the removed / desilted / floating material up to any distance
for transportation or any other purpose including loading and also including all the
laboures component required for maintaining the smooth flow, sprinkling of the same by
52 approved disinfectant to avoid nuisance of pest including mosquitoes & flies and bad
smell, transporting the same to any distance via the specified Municipal weigh bridges to
the identified dumping sites to be provided by the bidder including loading/unloading of
the same etc. complete as directed by the Engineer in-charge.
Substructure
Top Slab MT 1 71.00 0.165 MT/Cum 11.72
Walls MT 1 52.00 0.145 MT/Cum 7.54
Raft slab MT 1 107.00 0.165 MT/Cum 17.66
Wing Walls MT 1 95.00 0.14 MT/Cum 13.30
Anti-crash MT 1 42.30 5.92
Barrier 0.14 MT/Cum
57.00 63.00
R3-BW-5-8 providing Fusion Bonded epoxy coating (FBEC) to reinforcing steel bars as per IS
13620-1993 specifications for coating thickness of 175 microns (with permissible
55 variation of 50 microns) including testing at plants etc. complete as per specifications.
Total
Sr. No. Item No. Description Unit Nos. Length Width Depth Quantity
Quantity
R3-BW-5-1-j Providing and fixing in position Drainage Spouts including trough of 260 x 260. size
fabricatede using mild steel plates, flats, MS grating, etc. and 100mm dia GI pipe 1 m
56 long as per detailed drawings etc. complete as specified and directed.
Nos 4 4.00
4.00 4.00
R3 -RT -16 -
34
Supplying/ fixing of Two Way Raised Pavement Markers made of polycarbonate
moulded body and reflective panels with micro prismatic lens capable of providing total
internal reflection of the light entering the lens face and shall support a load of 13635 kg
tested in accordance to ASTM D 4280 Type H and complying to Specifications of
57 Category A of MORTH Circular No RW/NH/33023/10 -97 – DO III Dt 11.06. 1997 .
The minimum reflective area of 13 SqCm on NOS side and the slope to the base shall be
35 +/ - 5 degree. Fixing will be without nails but by using epoxy resin based adhesive as
per manufacturer’s recommendation including site clearance complete as directed by the
engineer.'
Nos 2 2.00
2.00 2.00
CONSTRUCTION OF BRIDGE ACROSS LAXMI BAUG NALLAH ON MISSING 60 FEET DP ROAD LINK,FROM
GHATKOPAR EAST "N" WARD
Total
Sr. No. Item No. Description Unit Nos. Length Width Depth Quantity
Quantity
R3-RT-16-25 Mandatory Board (600mm dia) hanging on pole – Providing, Fabricating, Erecting on
site Mandatory & Cautionary Boards (of type 1S-A-3). As per the design incorporated in
Street Furniture catalogue volume –II published by M.C.G.M., Signage plaque (box)
shall be of size 600mm dia. Mounted on existing electrical pole with GL clamp. The box
shall be made of4mm thick fibre reinforced plastic box covering both sides of pole. The
cirCUMferential edge shall be closed with 3 mm thick FRP. The box shall be pasted with
MICRO PRISMATIC GRADE retro reflective base sheets on both sides conforming to
60 Type XI standards of I.R.C. 67 2012 CODE. Letters or borders to be pasted on this box
using transparent electro cuttable film. The reflectivity of sheet shall have guarantee
of10years. The reflection count shall not be less than 80% of its original reflection
after10years shown in the drawing complete as per specification and as directed by the
Engineer
Nos 2 2.00
2.00 2.00
R3-BW-5-3-f Providing and applying protective paint consisting of two coats of coal tar epoxy paint
over one coat of primer of approved quality and make to the external surfaces of concrete
61 structures to be buried under the soil etc. complete as specified and directed.
Total
Sr. No. Item No. Description Unit Nos. Length Width Depth Quantity
Quantity
R3-BW-3-11 Providing weep holes in Brick masonry/Plain/Reinforced concrete abutment, wing
wall/return wall with 100 mm dia PVC pipe, extending through the full width of the
65 structure with slope of 1V :20H towards drawing foce. Complete as per drawing and
Technical specifications
Each 12 12.00
12.00 14.00
R3-BW-8-50 RATE ANALYSIS FOR STEEL PLATE GIRDER FABRICATION &
ERECTIONProviding, detailing, fabricating and fixing at desired location using hot
rolled sections and M S Plates of high grade steel as per specifications and approved
fabrication drawings (which are to be prepared by Contractor and got approved from
Engineer), transporting to site and erecting/launching structural steel members/girders for
all heights & at all levels including provision of necessary erection/launching acsessaries
and machinary for erection/launching, bolts, fixing bolts, nuts, washers, cleats, stiffeners,
gussets, baseplate and all necessary fixtures and operations like preheating as per
specifications, straightening, bending, cutting, drilling, grinding, machining if specified,
welding, grinding and removing the welding burr and preparing surface for painting with
Sand blasting, metalizing and painting of loose fabricated components and girders with
sprayed aluminium followed by protective coating of painting outside running line
66 complete with contractor's own paint, other material, labour, scaffolding, consumable.
Note: The protective coating of paint shall be as follows:(i) First coat of Each primer to
IS:5666. (ii) One coat of Zinc Chromate primer to IS: 104 and two coats of aluminium
paint to IS:2339. Total Thickness will be not less than 200 micron. Guarantee period will
be 5 years including touching up with spray painting after erection etc complete as
directed by Engineer In Charge. E-350 Grade Steel
Total
Sr. No. Item No. Description Unit Nos. Length Width Depth Quantity
Quantity
0.00 0.00
R2-CS-DD-5 Demolishing stone rubble masonry manually/ by mechanical means including stacking
69 of serviceable material and disposal of unserviceable material within 50 metres lead as
per direction of Engineer-in-charge
Breaking of
Drain Bed Cum 1 50.00 1.50 0.30 22.50
Breaking of
SWD Walls Cum 2 50.00 0.30 1.50 45.00
Breaking of
SWD Top Slab Cum 1 50.00 1.50 0.30 22.50
Breaking of
SWD raft Cum 1 50.00 2.00 0.40 40.00
Ext. Structure
(track side) Cum 1 11.00 7.00 3.00 231.00
Ecah 3 3.00
3.00 4.00
R3-RW-3-22 Removing the paver blocks of any thickness, size & colour from carriage way or footpath
& transporting the same to ward depot or any where in BMC limit. The paver blocks
72 shall be stacked neatly at specified locations etc. complete as specified and as directed by
the Engineer.
Below SWD
PCC Cum 1 50.00 2.00 0.25 25.00
25.00 28.00
R3-SWD-15-A Providing and laying RMC (Ready Mixed Concrete) M-15 grade Plain cement concrete
in foundation including boxing,curing by any means, etc. complete as specified and/or as
74
directed by Engineer in Charge.
CONSTRUCTION OF BRIDGE ACROSS LAXMI BAUG NALLAH ON MISSING 60 FEET DP ROAD LINK,FROM
GHATKOPAR EAST "N" WARD
Total
Sr. No. Item No. Description Unit Nos. Length Width Depth Quantity
Quantity
23.00 26.00
R3-SE-8-2 Constructing brick masonary inspection chamber rectangular 0.9M x 0.6M and 0.6M
deep -do- including M 20, 30 cm thick cap c.c. Bedding & including C.I. extra heavy
duty air tight frame and cover weighing minimum 270kg complete as per description in
78 item No. R3-SE-8-1 with necessary centering etc. all complete as per plan and directed.
Road no 1 1
1.00 2.00
CONSTRUCTION OF BRIDGE ACROSS LAXMI BAUG NALLAH ON MISSING 60 FEET DP ROAD LINK,FROM
GHATKOPAR EAST "N" WARD
Total
Sr. No. Item No. Description Unit Nos. Length Width Depth Quantity
Quantity
R3-RW-7-47 Supplying and fixing 900 mm x 900 mm clear opening composite resin manhole cover
with two cover design of approved brand with 12.5 ton load capacity, as per EN-124
standard. Covers & frame shall have SS Nut bolt locking arrangement and top abrasion
resistant layer of decorative granite finish. Abrasion resistance shall be conforming to
IS15658:2006 and permissible permanent set value of 6mm for each cover, after
application of 2/3 test load in five continuous applications as per EN-124. The testing
shall be performed in fully equipped and NABL certified test lab with random batch test
(2% of lot size) as per testing procedure stated in EN-124 standard, including testing,
79 inspection of material sample and finished product in presence of Engineers (2nos.) at
Manufacturer's work place, etc. complete as specified and as directed by Engineer-in
Charge. (Inspection shall be as per guidelines of EN-124-2015 standard specifications.)
Total
Sr. No. Item No. Description Unit Nos. Length Width Depth Quantity
Quantity
R3-RW-10-57 Extra Over item of stencil concrete above M20 in footpath. Providing, applying and
finishing the topsurface of M-20 concrete with stamp/ stencilof approved pattern and
colour, inaccordance with manufacturer's specificationof any approved brand of colour
hardener @of 3.5 kgs/m2; including floating of colourhardened over concrete surface
with differenttypes of floaters; including application ofrelease agent @ of 0.15 kgs/m2,
stampingover the concrete surface with stampingtools; including cleaning of surface
withwater and cutting of finished concrete;including application of two coats of
acrylicbased sealer for finishing. Colour hardenerand release agent shall be tested
83 forabrasion resistance for a depth of wear,should not be more than 0.025 mm.Coverage
of sealer should not be more than6.5 sq.m per one litre coat; including cost ofskilled
manpower, cutting machine, sprayerand all tools tackles for all activities; complete
smooth & finish as per direction ofEngineer-In-Charge.
Stamp Concrete
over footpath
100.00 110.00
R3-SE-14-5 Providing, Laying and Jointing of 160mm dia (OD) HDPE pipe (PN 6 Class-PE 80
grade: IS 14333) to correct grade and alingnment upto 2.1 m depth including boring,
Pilot inclined dilling from exisitng ground level upto required depth (invert level) on rig
side of proposed gravity sewer line (i.e. entry side) using Horizontal Directional Drilling
84 method in any type of ground including soft soil, mixed ground and soft/hard rock.
Length of gravity sewer line i.e. actual pipe laid will be considered for measurement.