Professional Documents
Culture Documents
Lutron HomeWorks P5 Processor TCP-IP Manual
Lutron HomeWorks P5 Processor TCP-IP Manual
Lutron HomeWorks P5 Processor TCP-IP Manual
Revision History
Revision 1.1, 8 / 2007
Pertains to HomeWorks IlluminationTM software version 1.22 or newer. The upper port range
for Telnet, FTP, and HTTP has been increased from 32767 to 65535.
The HomeWorks installer will make any necessary changes to the P5 processor and the network
professional can make any necessary changes to the networking equipment. Use the worksheet at
the end of this document to record the P5 processor configuration(s).
This specification applies to the current (non-beta 1.22) or newer versions of the HomeWorks
IlluminationTM software.
Protocols Used
• TCP, UDP, IP, ARP, DHCP, ICMP, TELNET, FTP, NBNS
TCP / IP Settings
• DHCP or static* configuration <factory default = DHCP>
• IP Address*: <static or dynamic configuration>
• Subnet Mask*: < static or dynamic configuration>
• Gateway*: <static or dynamic configuration>
• Telnet Port: <factory default = 23>
• FTP Port: <factory default = 21>
• HTTP Port: <factory default = 80>
• Ping Response: Enabled <factory default = Enabled, can be Disabled>
• NetBIOS Name: <factory fixed to = HOMEWORKS>
• NetBIOS Name is case insensitive
* If DHCP is set to Disabled, the following are the default values:
IP Address: 192.168.250.<processor address = 1 through 16>
Subnet: 255.255.255.0
Gateway: 0.0.0.0
FTP Server
• Used during HomeWorks Illumination database uploads and database extractions
• Non-modifiable login, used exclusively by the Illumination software
• Active mode FTP server, does not support Passive mode FTP transfers
• FTP Command Port number is user modifiable <factory default = 21>
• FTP Data Port number is always the Command Port value minus one <factory default = 20>
• FTP Command Port range is 2 through 65535
• Used to store HomeWorks Illumination data, no user storage capability
• Single session only
• FTP service can be disabled by setting the port number to zero
HTTP Server
• Used to display Web Keypads only
• Works with Microsoft® Internet Explorer® 6.0 or higher, Mozilla® Firefox®,
and Apple® SafariTM web browsers
• Requires web browser Cookies to be enabled
• Requires Java Script 1.2 or better to be enabled
• Requires web browser support for Cascading Style Sheets
• Display resolution should be 800 x 600 or better
• HTTP Port is user modifiable. <factory default = 80>
• Modifiable range for the port is 1 through 65535
• Only one processor in a multiprocessor system hosts Web Keypads
• Web Browser can use NetBIOS name or IP Address of HTTP enabled processor
• Web keypad access can be password protected
• Sixteen user definable web keypad user names and passwords
• The login names and passwords are limited to a maximum of 32 characters each
• The characters used for login and password are limited to characters: a-z, A-Z, 0-9
• HTTP service can be disabled by setting the port number to zero
Apple is a registered trademark and Safari is a trademark of Apple, Inc. This document is an inde-
pendent publication and has not been authorized, sponsored, or otherwise approved by Apple Inc.
IEEE is a registered trademark of The Institute of Electrical and Electronics Engineers, Inc.
Lutron, HomeWorks, and the sunburst logo are registered trademarks, and the HomeWorks logo is a
trademark of Lutron Electronics Co., Inc.