Professional Documents
Culture Documents
r10 04c m3 Parker Pneumatic Regulator Datasheet
r10 04c m3 Parker Pneumatic Regulator Datasheet
P AT
K 39 5 56 7
A
E NT
PU
LL
C
LO
B • Panel Mountable
• High Flow: 1/4" - 80 SCFM§
N N
E
B B
3/8" - 80 SCFM§
1/2" - 100 SCFM§
R11 R10
• R10: Push-to-Lock, Pull-to-Adjust.
Adjusting Lock is engaged when Knob is
Removed Rendering Unit Tamper Resistant
• R11: Heavy Duty Tee Handle Adjustment
Ordering Information
R 10 — 02 C /**
Technical Information
Flow Characteristics Flow Characteristics
R10-02C / R10-03C R10-04C
100 100
1/2 Inch Ports
Secondary Pressure - PSIG
1/4 & 3/8 Inch Ports
Secondary Pressure - PSIG
Secondary Pressure - bar
Secondary Pressure - bar
6 100 PSIG (6.9 bar) Primary Pressure
100 PSIG (6.9 bar) Primary Pressure
75 5 75
5
50 50
3
3
5
5
B
1 1
0 0 0 0
0 10 0 30 0 50 60 70 80 90 0 0 0 60 80 100 10
Rated Flow - SCFM Rated Flow - SCFM
0 10 0 30 0 0 10 0 30 0 50
Flow - dmn3/s
Flow - dmn3/s
! WARNING ! CAUTION:
Product rupture can cause serious injury. REGULATOR PRESSURE ADJUSTMENT – The working range
Do not connect regulator to bottled gas. of knob adjustment is designed to permit outlet pressures within
Do not exceed maximum primary pressure rating. their full range. Pressure adjustment beyond this range is also
possible because the knob is not a limiting device. This is a
common characteristic of most industrial regulators, and limiting
devices may be obtained only by special design.
For best performance, regulated pressure should always be set
by increasing the pressure up to the desired setting.
Pneumatic Division
B25 Richland, Michigan
www.wattsfluidair.com