Professional Documents
Culture Documents
Kodak Inverter User Settings Guide 1.1
Kodak Inverter User Settings Guide 1.1
The following application note will guide you on how to identify and resolve the error 61 on the
Kodak inverters when paired with a Pylontech battery.
Due to the ongoing chip shortage and the ongoing pandemic. Pylontech and Kodak was forced to
change certain chips which caused compatibility issues.
The following is recommended as a solution if you have error 61 on your Kodak inverter when paired
with a Pylontech battery.
To identify if your specific inverter is affected, please take a look at the U2 version of the firmware.
This can be done on the main screen and pressing the down arrow button until you see U2:
(firmware version). The following firmware versions are affected:
• OG-PLUS5.48 – U2: 102.71
• OG-7.2 – U2: 112.14
• OGS5.6 – U2: 36.01(Please note the 3 dots in the middle between the numbers 36 and 01)
Once you have identified that your product is affected, please follow the following steps.
1. Enter the programming menu on the Kodak inverter and navigate to setting 05. To navigate
the menu please consult the user manuals:
a. OGS5.6 – Page 15
b. OG-PLUS5.48 – Page 14
c. OG-7.2 – Page 16
2. Change setting 05 to USE
3. Next, we want to change the bulk charge, float charge and cut-off voltage. These are settings
26, 27 and 29 respectively. Please change the values as stated in the table below depending
on which battery is installed:
Battery Bulk charge Float charge Cut-off voltage
US2000C 53.2V 53.2V 46V
US3000C 53.2V 53.2V 46V
UP5000 53.2V 53.2V 46V
BL3.6 56.4V 56.4V 49V
4. Your system will now function as normal. Segen Solar will contact you once the firmware
issue has been resolved.