Calculation of the die width
Selection of the die width
‘= The inner radius is a function of the die width and the punch radius.
= The die width is defined by the sheet thickness and the side length
= The minimum die width is defined by its stability under load.
ev W030"
‘vos a0
£2v004 3 20"
30°
kevwr2a0"
evo06 30
kev wenn"
Ev007 30°
EvOOr 30"
aware”
0,5-2,6mm
3,0- 8,0 mm
axs
Maximum load of dies
9,0- 12,0 mm
10xs
84° 80° 90°
o Be Bow
<8: 828
Brew Binsin Seeeuer | stu
EV wed" aon kNtm eo ‘s00 av EV040 90" 1100 kN'm:
VIS Wad 250kNIN [EV WOO” ogy, SVOUDS SO" 290 EW
" Eee binsiso” oo
Evmuens 400% ey ysi80r Evoens 90" | 460m
EvH weno ‘800k
evswase soem inioso" oo
Eywi9nt sox EVN eincass0_| sos
Symone soem evosar nm
a eee
Prwane
evn wires SOOKNM EV yizmi60* 1600 Km EVOA SO" 400 even
Prswisse ssa
‘Evid wierea 700 KN
‘Evi woes 700 KNPress force table
(recommended values)
Press force required for 90° air bending
Material: sown ses v v v v v
12 197 18 1
4
28
ot
131
208
208
7d
218
au
428
505
930
1339 7159)
190
214 743
313331 207
B15 454 405 05
805 710 634 575415
91 754 sor
1597 1427 1178. 933
2508 2004 1650, |
J
aeeeeas
ae
108 08 7464
169 137 116 100 78
318 244 108 165 144 113
433382 209 207 195.153
vas 352. 200
‘550 402 360 (313
574451
782614 505,
201 000
1014 835,
2 Fim
258
‘bi= min. lange length at max. sheet thickness (die 94
'b2= min: flange length at max. sheet thickness (die 30
Riwas determined by tests at optimum sheet thickness. Fink
t2 he folowing upper co ras:
Enos Re PSO SO Ra
All values af
Wass. RO,