Professional Documents
Culture Documents
Thermofisher Precision Water Level Regulator Kit 3166211 - Instruction Sheet-3164596 - Rev 0 PDF
Thermofisher Precision Water Level Regulator Kit 3166211 - Instruction Sheet-3164596 - Rev 0 PDF
Installation Perform the following steps. Refer to figures on the pages following.
1. Turn off unit, disconnect power and drain water from the bath.
(Remove unit if mounted in countertop.)
Note To ensure a good seal, wrap threads with teflon tape or equivalent
sealer. ▲
Continue to Step 7.
Continue to Step 7.
7. Insert the plastic tubing, from the bottom of the water level regulator,
into the elbow connector, at the drain, and tighten the elbow connector
fitting firmly to ensure a good seal. Tabletop unit can now be
remounted into table opening.
8. Uncoil Tygon tubing and press onto 1/4" Hose Barb Fitting, located at
the top of water level regulator.
9. After refilling bath with water, hook-up other end of the tygon tubing
to water supply and turn on water supply. Minimum pressure is
approximately 15 PSI, maximum is approximately 75 PSI.
Bath
Drain
Elbow
Water Level
Connector
Regulator
Plastic Tubing
Figure 1. Side View
TO
WATER
SUPPLY
Double-sided Tape
(on bracket)
Bracket
Bath Table
Frame
4-1/4”
The material in this instruction sheet is for information purposes only. The
contents and the product it describes are subject to change without notice. Thermo
Fisher Scientific makes no representations or warranties with respect to this
instruction sheet. In no event shall Thermo be held liable for any damages, direct
or incidental, arising out of or related to the use of this instruction sheet.
0 -- 6/2/05 Corporate Standards format (Winchester inst. sheet #542544, kit #51200832) ccs
Rev ECR/ECN Date Description By