ee
B 8201-1987
Fig. 6.1
(a) Dished head (®) Semf-ehipsoidal (c) Flat head
head
i
7 Th :
ao) M0 EC
iy LL
ae n
6.3 Minimum Thickness of Dished Heads or Full-Hemispherical Heads with
te Pressure of the Concave Side, Without Slay ‘The mittee THE a
“dished heads or full-hemicpherical heads with the pressure on the concave
side without stay shall be determined by the following formula.
oD.
(1) For Blank Heade
ge RW.
Wie.y—O2P *
(2) For Heads with Openings
{8) Reinforcements of openings shell conform to the provisions in 11,
In thic case, the minimum Uckuess of the head shall conform to
the formula in (1), except the following case of (b).
aap +]
(®) In case «head has 2 flayed opening exceeaing 150 mm in the
largest dimension, which is reinforeed conforming to 11.2.1 (2),
the thickness of the head shell be increased by not less than 13
of the thickness calculated by the formula in (1) and by at least
3mm.
in this case, when the inside radius of the head R is lese than
80 & of the inside diameter of the shell (including the case of full-
homisphoxical heads) aiid ue head plate thickness is calculated by
above formula, & shall be considered es 80 of the inside diameter
of the shell. However, the head fitted with flue shall conform
to the following (3).-
(3) For Dished Heads with Flues
For Dished Heads with Flues
= PR.
‘Bag t#
where, in (1) and (3)
13° aiinimum thickness of the head (mm)
P: maximum working pressure (Igf/em?) {MPa}
R: inside radius of the full-hemispherical head or
iuside radius of the central segment of the dished
head (mm)
Ge: allowahle tensile etreas of the material (hyf/mm*)
{N /mm?}