40
NVA rere Ne. ol
Power Output, 8 Watts
Rs Rig
Parts List
€1, Cx=100 pF, dise-ceramic,
$00 V
.05 uF, paper, 200 'V
uF, electrolytic, 450 V
6 uk, electrolytic, 450 V
5 UF, electroly tie, 450 V
crystal microphone input ;
max. input: 2 millivolts
peak
Jo=Jack for erystal phono-
pickup input
Li=Filter choke, 5 H,
200 mA, United Trans-
300 ohms, 0.5 watt
47 megohm, 0.5 watt
Rir=0,15 megohm, 0.5 watt
Ris=180 ohms, 2 watts
Ris=47000 ohms, 1 watt
Ra=50 ohms, 10 watts
Res=8200 ohms, 2 watts
1 uF, paper, 200 V
001 uF, dise-coramic,
300 V
o=0.01 uF, disc-ceramic,
300 V
Ci0=470 pF, dise-eeramie,
300 V.
4700 pF, dise-ceramic,
0 Vv.
4 uF, electrolytic, 450 V
Cis=0.05 uF, paper, 600 V
Cu=25 uF, electrolytic, 25 V
Cis, Cio, Cr=20 uF, electro-
lytic, 450 V.
Fi=Fuse, 1 ampere
Jn=Jack for high-impedance
former Corp. R20 or equiv.
Ryw=10000 ohms, 0.5 watt
=Volume Control, potenti-
neter, 1 megohm
Re=2.2 megohms, 0.5 watt
Ri, Rs, Roo=0.22 megohm,
0.5 watt
200 ohms, 0.5 watt
|-1 megohm,
watt
Ro, Ru=Tone control, po-
tentiometer, 0.5 megohm.
22000 ohms, 0.5 watt
2000 ohms, 0.5 watt
‘Microphone-phonograph
selector ; wafer switch ;
single-pole, double-throw
ON-OFF switch, single-
pole, single-throw
‘T:=Power transformer, 300-
0-300 V., 90 mA. ; 6.3 V.
3.5 A., center tapped; 5 V.,
2.A, Thordarson 22R04 or
equiv.
‘To=Output transformer for
‘matching impedance of
voice coil to 4000-ohm tube
load; 10 watts ; United
‘Transformer Corp. S14 or
Circuit Description
‘This microphone and phonograph
amplifier can deliver up to 8 watts of
audio output‘ power for an input of
200 millivolts rms at J: (phonograph
input) or an input of 6.8 millivolts
rms at J, (microphone input). The
amplifier uses a 6EU7 twin-triode
input amplifier, a 6AV6 driver stage,
equiv.
and a 6L6GC single-ended output
stage to increase the signal power
from a high-impedance crystal micro-
phone or crystal phonograph pickup
to the desired level. The transformer-
coupled ac input power is converted
to de operating power for these
stages by a 5Y3GT full-wave recti-