Professional Documents
Culture Documents
Operation: Connections and Settings Communication Unit 560CMU02 R0001
Operation: Connections and Settings Communication Unit 560CMU02 R0001
Application, characteristics and technical data The connection to the RTU560 serial peripheral
have to be taken from the hardware data sheet: bus is done via 48 pole DIN-F socket connector
according to DIN 41612. The serial peripheral bus
is not available on the RJ45 connectors on the
560CMU02 R0001 1KGT 150 595 front plate.
CPA Interface
Operation The CPA interface is available on the RJ45
The communication unit 560CMU02 R0001 is one connector on the front plate. It can interface
of the CMU boards (CMU = communication unit) RS485 signals. The RS485 bus mit be terminated
of the remote terminal unit. The 560CMU02 on both sides by a 1 k resistor. The termination
R0001 controls process events and on the CMU side is already done on board.
communications with control centers and local
The settings have to be done by RTUtil560
MMI systems via up to three serial interfaces configuration tool. The signals are used according
(CP1, CP2, CPA) and the Ethernet
to Fig. 2:
10BaseT/100BaseT LAN interface (E).
Pin Signal
1 - Not used
2 TA Data -
RJ45
3 TB Data + 1
4 - Not used 8
7 - Not used
8 -
4 Not used 8
5
Jack
6 RD - Input
7 Not used
The following parameters have to be defined for The settings of the Ethernet interface are
all protocols:
node name
Baudrate: 50 to 19 200 baud
IP address
Modem control:
Subnet mask
Direct link (TxD/RxD only)
Default gateway
WT link full duplex (RTS/CTS handshake)
connected stations
WT link half duplex (RTS/CTS
number of the host interface.
handshake)
WT link half duplex (RTS/DCD
handshake)
Dial up (external modem DCD
handshake)
Loop switch unit DSTC 3002 (RP570/71
Host interface only)
Link with collision avoidance (TxD, RxD,
DCD, without handshake (DNP 3 only)
Note:
We reserve the right to make technical changes or modify the contents
of this document without prior notice. With regard to purchase orders,
the agreed particulars shall prevail. ABB AG does not accept any
esponsibility whatsoever for potential errors or possible lack of
information in this document.
We reserve all rights in this document and in the subject matter and
illustrations contained therein. Any reproduction, disclosure to third
parties or utilization of its contents - in whole or in parts –is forbidden
without prior written consent of ABB AG.