Professional Documents
Culture Documents
Sharp lcdtv-269 Lc52e77un (A) Tech Bulletin PDF
Sharp lcdtv-269 Lc52e77un (A) Tech Bulletin PDF
Model(s): LC52E77UN(A)
Subject: No Power and Power LED is flashing 1X
Symptom: TV will not turn on and front indicator LEDs are flashing. TV may in some cases come on
and exhibit flashing backlights. Most commonly occurs when the TV is used for the very first time.
Solution: Properly seat the Inverter Unit(s) fully into a locked position.
Steps to Repair:
1) Refer to disassembly procedure for Rear Cabinet as described in Service Manual
2) Examine both Inverter Units to see if they are improperly installed. (See FIGURE 1)
3) If either or both Inverter Units are not properly seated please apply minimal force onto PWB, nearest the
clips, to lock it into place. (See FIGURE 2)
Steps to Reset:
4) Hold in INPUT & VOLUME DOWN buttons on the TV
5) Continue to hold in the buttons and plug in the TV
6) TV will turn on by itself and a small “K” will now be present on the screen in the upper left
7) Release both buttons
8) Simultaneously press CHANNEL DOWN & VOLUME DOWN one time on the TV
9) Service Menu should now be showing
10) If “LAMP ERROR” shows other than a Zero please reset it (Refer to Service Menu Detailed Instructions Page 4)
11) If Monitor Error Cause is other than ZERO please reset it (Refer to Service Menu Detailed Instructions Page 4)
12) Perform Industry Init (Refer to Service Menu Detailed Instructions Page 4)
13) Unplug the TV upon completion of Industry Init (green screen)
14) Wait 30 seconds and plug in TV
Steps to Test:
15) Check the TV for functionality and POWER ON / OFF several times
16) Unplug the TV after testing is successful
17) Repeat steps 4 thru 9 to ensure that no errors are present
INVERTER UNITS
FIGURE 1