Professional Documents
Culture Documents
Determining The Specifications of Gears - KHK
Determining The Specifications of Gears - KHK
DETERMINING THE SPECIFICATIONS OF GEARS
TOP > Gear Knowledge > Gear Technical Reference > Determining the Specifications of Gears
Steps
4. Measure the span measurement of k and the span number of teeth. Also, measure the k –1. Then calculate the difference.
NOTE.
This table deals with the pressure angle 20 deg and 14.5 deg only. There maybe cases where the degree of the pressure angle is different. Tooth profiles
come with deep tooth depth or shallow tooth depth, other than a full tooth depth.
Given the lead pz, number of teeth z normal module mn, the helix angle β can be found with the equation:
The number of teeth z and normal module mn can be obtained using the method for spur gears explained above. In order to obtain pz, determine da by
measuring the tip diameter. Then by using a piece of paper and with ink on the outside edge of a helical gear, roll it on the paper pressing it tightly. With a
protractor measure the angle of the mark left printed on the paper, βa. Lead pz can be obtained with the following equation.
Related links :
齿轮技术资料