Professional Documents
Culture Documents
Habilis Pec Refresher 1
Habilis Pec Refresher 1
PEC 2009
Multiple Choice. Select the correct answer for each of the following questions. Mark only one
answer for each item by shading the box corresponding to the letter of your choice on the
answer sheet provided.
32. What is the size in square millimeters (mm2) of the cable 250 MCM in size?
a.) 150 mm2 c.) 125 mm2
b.) 135 mm2 d.) 145 mm2
33. Direct burial cables or conductors with nominal voltage of 600 V or less and passes under
streets, hi-ways, roads, alleys, driveways and parking lots shall have a minimum cover
distance of ____.
a.) 500 mm c.) 460 mm
b.) 600 mm d.) 550 mm
34. What is the secondary voltage of a transformer that has a primary voltage of 100 V, primary
turns of 200 and secondary turns of 40?
a.) 500 V c.) 4 V
b.) 25 V d.) 20 V
35. A single electrode consisting of rod, pipe or plate shall have a resistance to ground of ____
or less.
a.) 20 ohms c.) 25 ohms
b.) 15 ohms d.) 30 ohms
36. Where the overload relay selected using the factor 125% is not sufficient to start the motor
or to carry the load, the multiplying factor shall be increased but shall NOT exceed ____
percent.
a.) 130 c.) 150
b.) 140 d.) 125
37. A 15 hp, 220 V shunt motor has an efficiency of 87% at full load. The resistance of the field
is 440 ohms. What is the full-load armature current?
a.) 67.59 A c.) 75.69 A
b.) 57.96 A d.) 49.58 A
38. Before starting any installation work, alteration, repair or extension on any electrical system,
what type of permit is needed?
a.) building permit c.) electrical permit
b.) working permit d.) mayor’s permit
39. Dry type transformers rated over ____ volts, shall be installed in vaults.
a.) 25,000 c.) 35,000
b.) 10,000 d.) 50,000
40. Rigid non-metallic conduit shall be supported within _____ of each box, cabinet or other
conduit termination.
a.) 900 mm c.) 800 mm
b.) 760 mm d.) 600 mm
41. What type letter for conductors has a trade name “moisture and heat resistant rubber”?
a.) RH c.) XHHW
b.) RHW d.) THW
42. Find the cost of running a 100 W, 220 V lamp for 20 hours at P 3.00 per kW-hr.
a.) P6.00 c.) P10.00
b.) P12.00 d.) P8.00
43. Before using a megger it should be tested by placing the test leads together and turning the
crank. What will be the reading to indicate that the leads and megger are in good condition?
a.) between 100 to 1,000 c.) below 100
b.) above 1,000 d.) 0
44. Where installed in raceways conductors size ___ and larger shall be stranded.
a.) 5.5 mm2 c.) 14 mm2
b.) 8.0 mm2 d.) 3.5 mm2
45. What is the maximum number of overcurrent devices of a lighting and appliance branch
circuit panelboard shall be installed in any cabinet or cutout box?
a.) 42 c.) 45
b.) 50 d.) 48
46. A grounded metal enclosure containing factory mounted, bare or insulated conductors,
which are usually copper, or aluminum bars, rods or tubes.
a.) cable tray c.) wireway
b.) busway d.) cable bus
47. How much charge is stored in a 2 μF capacitor connected across a 50 V supply?
a.) 100 μC c.) 200 μC
3
RME Bernard E. 4
4
RME Bernard E. 5
PEC
Multiple Choice. Select the correct answer for each of the following questions. Mark only one
answer for each item by shading the box corresponding to the letter of your choice on the
answer sheet provided.
40. Rigid non-metallic conduit shall be supported within _____ of each box, cabinet or other
conduit termination.
a.) 900 mm c.) 800 mm
b.) 760 mm d.) 600 mm
41. What type letter for conductors has a trade name “moisture and heat resistant rubber”?
a.) RH c.) XHHW
b.) RHW d.) THW
42. Find the cost of running a 100 W, 220 V lamp for 20 hours at P 3.00 per kW-hr.
a.) P6.00 c.) P10.00
b.) P12.00 d.) P8.00
43. Before using a megger it should be tested by placing the test leads together and turning the
crank. What will be the reading to indicate that the leads and megger are in good condition?
a.) between 100 to 1,000 c.) below 100
b.) above 1,000 d.) 0
44. Where installed in raceways conductors size ___ and larger shall be stranded.
a.) 5.5 mm2 c.) 14 mm2
2
b.) 8.0 mm d.) 3.5 mm2
45. What is the maximum number of overcurrent devices of a lighting and appliance branch
circuit panelboard shall be installed in any cabinet or cutout box?
a.) 42 c.) 45
b.) 50 d.) 48
46. A grounded metal enclosure containing factory mounted, bare or insulated conductors,
which are usually copper, or aluminum bars, rods or tubes.
a.) cable tray c.) wireway
b.) busway d.) cable bus
47. How much charge is stored in a 2 μF capacitor connected across a 50 V supply?
a.) 100 μC c.) 200 μC
b.) 25 μC d.) 120 μC
7
RME Bernard E. 8
48. Hazardous locations where combustible dust is not normally in the air in quantities sufficient
to provide explosive or ignitable mixtures, and dust accumulations are normally insufficient
with the normal operation of electrical equipment.
a.) Class II, Division 1 c.) Class III, Division 1
b.) Class II, Division 2 d.) Class III, Division 2
49. What is the minimum insulation resistance of a building’s electrical wiring for circuits using
2.0 mm2 or 3.5 mm2 conductors?
a.) 500,000 ohms c.) 1,000,000 ohms
b.) 250,000 ohms d.) 750,000 ohms
50. What is the common tripping time for 60 Hz circuit breaker?
a.) 6 cycles c.) 7 cycles
b.) 8 cycles d.) 5 cycles