Professional Documents
Culture Documents
Service Newsletter: Product: Subject: NL: Date: Summary
Service Newsletter: Product: Subject: NL: Date: Summary
Service Newsletter: Product: Subject: NL: Date: Summary
Project:03-XXXX
Product: Freedom® Combo NL: Reissue 2111-097
Subject: New DVD Multidrive Replaces Freedom Workstation DVDs Date: March 15, 2005
Summary: A new IDE DVD Multidrive SW-9573-C, PN 0503088, is now being shipped with all
Freedom Workstations replacing the older DVD drive, PN 0502771.
Attached to this newsletter is the Multidrive Technical Fact Sheet which will also be available
in the next update of the Freedom Service Manual, PN 0889513, Section 7, Reference
Diagrams.
If it is necessary to order a new drive, only the IDE DVD Multidrive can be ordered as a
replacement for the older drive. The order must include an IDE ribbon cable, PN 0146064,
which is not included with the DVD Multidrive.
Service Policy: Not Applicable
Author(s): Terry R. Thorne
Editor(s): Technical Editor: Richard Piper
Requirement(s): See page 2 for required parts, recommended tools, and reference documents.
Return Policy: Not Applicable
Distribution: ; Everyone; ; APP Customer; ; CSP Customer; ; Dealer; ; Employee
Reference Documents:
In addition to this document, refer to the following document(s) for additional service
and operational information.
Document
Service/ATS Title
Number
PN 0889513 Service Freedom Series Hardware/Software Service Manual V1.2 and V1.3.
Note: Information on the following pages was taken from the Panasonic
DVD Multi-Drive Operating Instructions for Models LF-M721U /
LF-M721E. For additional detailed information see the Panasonic
Manual online: M721UE-1.PDF.
U Freedom Systems
S
E Panasonic Multi Drive
D
SW-9573-C
O
N 503088 Sheet 1 of 9 Issue 1 03/14/05
PANASONIC DVD MULTI DRIVE SW-9573-C, PN 0503088
Specifications
FIGURE 1 Specifications
U Freedom Systems
S
E Panasonic Multi Drive
D
SW-9573-C
O
N 503088 Sheet 2 of 9 Issue 1 03/14/05
PANASONIC DVD MULTI DRIVE SW-9573-C, PN 0503088
Specifications Continued
U Freedom Systems
S
E Panasonic Multi Drive
D
SW-9573-C
O
N 503088 Sheet 3 of 9 Issue 1 03/14/05
PANASONIC DVD MULTI DRIVE SW-9573-C, PN 0503088
SEE NOTE
Media Disc 2.6 GB and 5.2 GB DVD-RAM can be read, but cannot be
written to.
U Freedom Systems
S
E Panasonic Multi Drive
D
SW-9573-C
O
N 503088 Sheet 4 of 9 Issue 1 03/14/05
PANASONIC DVD MULTI DRIVE SW-9573-C, PN 0503088
A: Front Panel:
a. Operation Indicator Lamp
Steady Green: Disc inserted in the drive
Steady Orange: Recording, playback or tray opening/closing
Flashing Green: Error - The operation indicator lamp blinks to indicate malfunction.
Note: See Panasonic DVD Multi Drive M721UE-1.PDF, page A40, for error
explanation. See page A41 for troubleshooting information and pages A42 through
A46 for proper handling of Discs types.
b. Manual Eject Hole
Used to manually eject the tray in the event it doesn’t eject normally using the
open/close button or software commands. Turn off the computer and use this procedure
as a last resort as it can cause malfunction.
c. Open and Close Button
d. Shutter
B: Rear Panel
a. Audio Output Connector, b. Jumper Connector (see next page), c. IDE Connector,
d. Power Supply Connector, and e. Unassigned Connector
C: Side Panels
When securing this drive to a computer or other device, secure the drive with the
provided mounting screws into the areas as indicated (either upper or lower holes
depending on system). You can also use the four holes on the bottom to secure the
drive.
U Freedom Systems
S
E Panasonic Multi Drive
D
SW-9573-C
O
N 503088 Sheet 5 of 9 Issue 1 03/14/05
PANASONIC DVD MULTI DRIVE SW-9573-C, PN 0503088
Settings and Connections
Drives are usually set as Masters at time of shipment and must be properly configured when installed. There is a
jumper pin switch on the rear panel of the drive. Use caution when mounting the jumper pins. Do not mount the
jumper pin sideways or in any position other than specified. This can cause the drive to malfunction.
U Freedom Systems
S
E Panasonic Multi Drive
D
SW-9573-C
O
N 503088 Sheet 6 of 9 Issue 1 03/14/05
PANASONIC DVD MULTI DRIVE SW-9573-C, PN 0503088
Connecting the Drive to the Computer
Mounting screw holes are located in eight places on the right and left panels of the drive, and in four places on the
bottom panel. When securing the drive into a computer or other device, secure the drive firmly in place with four
mounting screws (included) in four places on the right and left panels or in four places on the bottom panel. Note:
Only use the screws included with the drive. Using screws with a different length or diameter may damage the
drive.
U Freedom Systems
S
E Panasonic Multi Drive
D
SW-9573-C
O
N 503088 Sheet 7 of 9 Issue 1 03/14/05
PANASONIC DVD MULTI DRIVE SW-9573-C, PN 0503088
FIGURE 9 Connections
U Freedom Systems
S
E Panasonic Multi Drive
D
SW-9573-C
O
N 503088 Sheet 8 of 9 Issue 1 03/14/05
PANASONIC DVD MULTI DRIVE SW-9573-C, PN 0503088
Inserting DVD-RAM, DVD-R and other Discs
A: DVD-RAM Discs
a. DVD-RAM disc b. Label and c. Tray
1. Insert so the label-side of the shutter is facing up. 2. Push the DVD-RAM disc about 2 cm towards the drive.
3. Press gently on the shutter-label so the DVD-RAM disc sits firmly on the tray.