Professional Documents
Culture Documents
11 Work Equipment-1 PDF
11 Work Equipment-1 PDF
1. STRUCTURE
A
A
29078WE01
8-154
2. REMOVAL AND INSTALL
1) BUCKET ASSEMBLY
(1) Removal
Η Lower the work equipment completely to
A
ground with back of bucket facing down.
B
45078AT08
8-174(2) 210-7
8-174(3) 210-7
(2) Install
Η Carry out installation in the reverse order
to removal.
When aligning the mounting position of
the pin, do not insert your fingers in the
pin hole.
ö Adjust the bucket clearance.
For detail, see operation manual
manual.
45078AT07
8-155
2) ARM ASSEMBLY
(1) Removal
ö Loosen the breather slowly to release
the pressure inside the hydraulic tank.
Escaping fluid under pressure can
penetrated the skin causing serious
injury.
Η Remove bucket assembly.
45078AT10
For details, see removal of bucket
assembly.
Θ Disconnect bucket cylinder hose (1).
5
Fit blind plugs in the piping at the
chassis end securely to prevent oil 1
from spurting out when the engine is
started.
Ι Sling arm cylinder assembly, remove 1
spring, pin stopper and pull out pin.
ö Tie the rod with wire to prevent it from
coming out. 8-175(2) 210-7
(2) Install
Η Carry out installation in the reverse
order to removal.
When lifting the arm assembly, always
lift the center of gravity.
ö Bleed the air from the cylinder.
8-156
3) BOOM ASSEMBLY
(1) Removal
Η Remove arm and bucket assembly.
Θ For details, see removal of arm and
bucket assembly.
Remove boom cylinder assembly from
boom.
For details, see removal of boom
cylinder assembly. 45078AT12
8-176(2) 210-7
4, 5, 6
3
45078AT11
(2) Install
Η Carry out installation in the reverse order
to removal.
When lifting the boom assembly,
always lift the center of gravity.
ö Bleed the air from the cylinder.
21078DA46
8-157