Professional Documents
Culture Documents
906-0034 WiAAPS-Quick-Guide-Rev-A
906-0034 WiAAPS-Quick-Guide-Rev-A
Overview WiAPB
Warranty void if WiAPB is installed upside down
Using WiAPC and Termination Board to provide power to WiAPBs
WiAPC Wireless
Communications
Pole
WiAPB
Termination board Field Wires 18V AC
18V AC Used for power only
For complete documentation visit http://www.pedsafety.com/product-installation-guides/ ©Campbell Company 2017 Tech Support: (208) 345-7459, option 2
WiAAPS Quick Guide
Cabinet wiring
Page #2
Terminals for Walk and Don’t Walk (120 V AC) in the cabinet
WiAPC
Φ2 PED Φ4 PED Φ6 PED Φ8 PED
Default IP: 192.168.1.101
Username: admin Antenna used for wireless communication
120 V
Neutral DW W DW W DW W DW W Password: password
WiAPC input
120V AC APB Power Place antenna on side of cabinet with
uses 25-pin line of sight to intersection where
conductor wireless APBs are located
cable
HIGH VOLTAGE 5
6
7
8
WiAPC output
Termination Board: It is recommended, for troubleshooting purposes to use the “A” terminals
low voltage connection
for power and “B” terminals as common. Also use termination board slot #1 for WiAPB ”1”,
uses 9-pin conductor
slot #2 for WiAPB “2”, and so on for all the push buttons. Stations are not polarity dependent.
cable
18 V AC Termination Board
Each WiAPB must have a unique ID number; Phases can be assigned to multiple WiAPBs.
Programming will be necessary to assign ID numbers and Phases to each WiAPB Station from
Utilizes the existing or new Field Wires
the WiAPC.
from cabinet to pedestrian push buttons
(for power only). Connect the Field Wires 4
from the cabinet on to the termination 3
board. 2 5
1
WiAPB 1
P6 = Phase 6
For complete documentation visit http://www.pedsafety.com/product-installation-guides/ ©Campbell Company 2017 Tech Support: (208) 345-7459, option 2