Professional Documents
Culture Documents
Ulenhancedsrschswitch PDF
Ulenhancedsrschswitch PDF
Ulenhancedsrschswitch PDF
Overview
Introduction:
The Purpose of the Trial is to improve UL IBLER and Throughput
UL Scheduling Triggering
The procedure for triggering UL scheduling is as follows:
1. Before transmitting data, a UE sends the eNodeB a scheduling request (SR) using the scheduling request indicator (SRI) on the PUCCH to
request UL resources for data transmission.
2. Upon receiving the SR, the eNodeB schedules the UE. (This type of UE is referred to as an SR UE.)
3. The SR UE transmits MAC protocol data units (PDUs), including the buffer status report (BSR), using the UL resources allocated by the
eNodeB.
4. If the BSR received at the eNodeB is greater than zero, the eNodeB continues scheduling the SR UE and data transmission on the SR UE
proceeds.
UlEnhancedSrSchSwitch specifies whether to enable UL SR-based scheduling optimization.
• When UlEnhancedSrSchSwitch is set to OFF,
o If the maximum number of retransmission attempts is reached but the SR UE still fails to transmit data, the BSR fails to be sent and
scheduling fails to start on the SR UE. In this situation, the eNodeB attempts to schedule the SR UE again and performs the attempt twice.
This process is referred to as re-scheduling for SR UEs.
o If the eNodeB falsely detects an SR from an SR UE in the dormant state of DRX mode, the eNodeB will schedule the SR UE for three
consecutive times and associated data transmissions will all fail when the maximum number of retransmissions is reached. In this situation,
the BLER increases.
DL Traffic Volume(GB) Average DL PRB usage UL Traffic Volume(GB) Average UL PRB usage