CESSNA AIRCRAFT COMPANY
402
MAINTENANCE MANUAL
BATTERY - CLEANING AND PAINTING
1. Cleaning Battery
AL
Clean battery with a mild solution of bicarbonate of soda (baking
soda) and water to remove acid corrosion.
NOTE: Remove battery from airplane before cleaning.
Rinse with clear water and sponge off excessive water and allow
battery to dry.
CAUTION: TAKE SPECIAL PRECAUTIONS TO ENSURE THAT BATTERY CELL FILLER
CAPS ARE TIGHT BEFORE CLEANING THE BATTERY. ENTRANCE OF
SODA WATER INTO BATTERY CELLS WILL NEUTRALIZE THE CELL
ELECTROLYTE.
CAUTION: DO NOT ALLOW ACID DEPOSITS TO COME IN CONTACT WITH SKIN OR
CLOTHING. SERIOUS ACID BURNS MAY RESULT UNLESS THE AFFECTED
AREA IS WASHED IMMEDIATELY WITH SOAP AND WATER. CLOTHING
WILL BE RUINED UPON CONTACT WITH BATTERY ACID.
Clean battery terminals as needed with a wire brush to brighten the
terminals for good electrical contact. Coat with petrolatun to pre-
vent corrosion.
2. Cleaning Battery Box
AL
Battery box should be cleaned with a strong solution of bicarbonate of
soda (baking soda) and water.
Clean hard deposits of spilled acid and corrosion products using a
wire brush.
When all foreign materials have been removed from the box, flush it
thoroughly with clean water.
After cleaning battery box, flush surrounding skin with clean water to
ensure that all corrosive material has been removed.
DO NOT ALLOW ACIO DEPOSITS TO COME IN CONTACT WITH SKIN OR
CLOTHING. SERIOUS ACID BURNS MAY RESULT UNLESS THE AFFECTED
AREA IS WASHEO IMMEDIATELY WITH SOAP AND WATER. CLOTHING
WILL BE RUINED UPON CONTACT WITH BATTERY ACID.
CAUTI
24-30-02
Page 701
Nov 2/81CESSNA AIRCRAFT COMPANY
MODEL 402
MAINTENANCE MANUAL
3. Acid Proofing Battery Box
A. Clean battery box. Refer to Cleaning Battery Box.
B. Sand corroded area of box. Ensure alll corrosion is removed
C.Mix polyester resin and hardener Methyl n-Propy! Ketone peroxide
(commercially available) per manufacturer's instructions.
D.Apply mixture to sanded area of battery box and allow to dry.
4, Cleaning Battery Sump Jar (Optional Battery Installation)
A. Remove sump jar from airplane (refer to removal installation procedures).
B. Empty jar and remove neutralizer pads.
C.Wash jar and pads thoroughly with clean water.
D.Saturate pads with a 3 percent-by-weight solution of boric acid and water and reinstall
in jar
E. Install sump jar per installation procedures.
24-30-02 Page 702
Jun 198