Professional Documents
Culture Documents
Permanent Packers PDF
Permanent Packers PDF
Permapak Accessories
Mill-Out Extension
A MOT Mill-Out Extension
is used in installations where
Seal Bore Extension floating seals are required due to
A MOT Seal Bore Extension tubing contractions. In addition,
is used in installations where this packer accessory provides
floating seals are required due a larger ID between a packer
to tubing contractions. This bore and a seal bore extension
packer accessory allows for allowing a packer plucker when a
a continuous seal bore and is packer is milled out.
available in lengths up to twenty
feet. Pump Out Plug
A MOT Pump Out Plug is
available with a choice of threads
Seal Bore to Mill-Out allowing the pump-out plug to be
Coupling attached to a packer, seal bore
extension, mill-out extension or
A MOT Seal Bore to Mill-Out tailpipe and hold pressure from
Coupling is used to connect below after the packer is set.
mill-out extensions to seal bore Once the production string is
extensions. landed, pressure is applied to the
tubing and the pump-out plug is
removed to allow full opening.
Knock-Out Plug
Concentric Coupling Bottom
A MOT Concentric Coupling When a MOT Knock-Out
is used to connect seal bore Bottom is run below the packer,
extensions to increase length. the knock-out plug allows a
packer to serve as a bridge plug
holding pressure from above and
below.
Permapak Accessories
Seal Unit
The MOT Standard Seal Units are
furnished with bonded nitrile rings and a
12-inch make-up length. These units may
be ordered in various lengths and with
severe service seal rings for high tem-
perature and corrosive environmental
conditions.
Hydraulic Permapak
The MOT Hydraulic Permapak hydrau- Special Features
lic-set seal bore packers are the hydrau-
X Uses proven Permapak components
lic set equivalent of the Permapak Seal
Bore Packers. The full range of Permapak X Compatible with Permapak options
Seal Bore accessories may be used with X Optional upper sealbore available
the Hydraulic Permapak.
X Single or dual bore option
Pressure sets the packer via a setting
chamber built into the tool. Pressure en-
ters the setting chamber via holes in the
polished packer bore. These holes can
be isolated with a ball-operated sub so
that other hydraulic operated tools can
be functioned before setting the packer.
Product Specifications
;L[[PUN ;L[[PUN
<VVS;PaL <VVS 7,
PUJOLZ
r
r =6; r =6. r
r
r
r )+5- r =6+ r
r