Professional Documents
Culture Documents
Ar BT Quiz 3
Ar BT Quiz 3
1. The tendency of most materials to move or deform overtime under a constant load. The amount of
movement varies enormously depending upon the material. The area that is highly stressed will move
the most. The movement causes stresses to be redistributed.
Creep
2. A continuous type of spread footing that supports vertical load the weight of the wall itself, and the
weight of the footing.
Wall footing
3. What is the equivalent diameter in millimetre of a Number 5 deformed bar?
16mm
4. Standard height and length of a 4” Concrete Hollow Block in mm?
200x400
5. Class B mixture?
1:2.5:5
6. Vernacular term for footing reinforcements
Parilya
7. Total board feet of 10 pcs. Of 3”x6”x18” is
27
8. Soil material suitable as fill or sub-grade, selected laboratory-approved pit-run gravel, disintegrated
granite, sand, shane, cinders or other similar materials with not more than 35% fraction passing the
No.200 sieve
Escombro bulik
9. To make cement plaster hold to the wall surface, what should be done
Apply in thin coats
10. Materials used to reduce or stop the penetration of moisture through the concrete. Reduces
permeability.
Damproofers
11. The minimum length of splice needed for column.
60cm
12. Consistency or plasticity of concrete mixes is measured with
Slump test
13. The materials used to slow down the hydration of cement especially during extreme hot weather
Retarders
14. The ability of a material to fix itself and cling to an entirely different material.
Adhesiveness
15. The ability of particles of a material to cling tightly to one another.
Cohesiveness
16. Important component to determine the strength of concrete
Water/ cement ratio
17. Vernacular term for rough plastering
Rebokada
18. Vernacular term for Concrete Hollow Block (CHB) laying
Asintada
19. What is a concrete beam placed directly on the ground to provide foundation for the superstructure?
Grade beam
20. The top chord of a truss resists what type of forces?
Compression
21. Standard gauge of tie wire
GA 16
1:3:6
23. Compressive strength of concrete mixture is measured with:
Cylinder test
24. Which of the following is not a Sheet Glass?
Insulating glass
25. A door made up of small horizontal interlocking metal slats which are guided in a track; the
configuration coils about an overhead drum which is housed at the head of the opening, either manual
or motor-driven.
Roll-up door