Professional Documents
Culture Documents
R&I Rear Axle Shaft
R&I Rear Axle Shaft
R&I Rear Axle Shaft
30-P-0620GH Page 1 of 4
MODEL 163.
P35.30-2018-09
12 Hexagon collared nut 37o Locking ring L6/3 Left rear wheel speed sensor
20a Bracket for rpm sensor 91a Follower joint
37 Rear axle shaft 97a Track rod joint
Remove, Install
7 Pull rear axle shaft (37) out of rear axle Do not damage the rubber boot or
shaft flange rpm sensor rotor.
8 Press rear axle shaft (37) out of rear Installation: To facilitate assembly AR35.30-P-0620-
axle center assembly turn the locking ring until the opening is 01GH
at the bottom.
9 Check joints and rubber boots for leaks If a joint is defective:
and damage
Replace entire rear axle shaft.
Track rod
Number Designation Model 163
BA35.20-P-1002-04B Self-locking nut, track rod joint to wheel carrier Nm 55
Wheel location
Number Designation Model 163
BA35.20-P-1002-07A Self-locking nut, follower joint of upper transverse control arm to wheel Nm 50
carrier
BA35.20-P-1006-07A Bolt, rpm sensor bracket to wheel carrier Nm 10
Rear axle
Number Designation Model 163
BA35.30-P-1001-01B Collared nut, rear axle shaft to rear axle shaft flange Nm 490