Professional Documents
Culture Documents
Foamstar® Si 2292 NC Sds en Us
Foamstar® Si 2292 NC Sds en Us
Foamstar® Si 2292 NC Sds en Us
FoamStar SI 2292 NC
Revision date : 2022/05/11 Page: 1/11
Version: 6.0 (30587205/SDS_GEN_US/EN)
1. Identification
FoamStar SI 2292 NC
Recommended use of the chemical and restriction on use
* The “Recommended use” identified for this product is provided solely to comply with a Federal requirement and is not part of
the seller's published specification. The terms of this Safety Data Sheet (SDS) do not create or infer any warranty, express or
implied, including by incorporation into or reference in the seller's sales agreement.
Company:
BASF CORPORATION
100 Park Avenue
Florham Park, NJ 07932, USA
2. Hazards Identification
According to Regulation 2012 OSHA Hazard Communication Standard; 29 CFR Part 1910.1200
Pictogram:
Signal Word:
Warning
Hazard Statement:
H227 Combustible liquid.
H319 Causes serious eye irritation.
H315 Causes skin irritation.
H302 Harmful if swallowed.
No specific dangers known, if the regulations/notes for storage and handling are considered.
2-butoxyethanol
CAS Number: 111-76-2
Safety Data Sheet
FoamStar SI 2292 NC
Revision date : 2022/05/11 Page: 3/11
Version: 6.0 (30587205/SDS_GEN_US/EN)
Content (W/W): >= 75.0 - <= 100.0%
Synonym: Butyl cellosolve
Cyclotetrasiloxane, octamethyl-
CAS Number: 556-67-2
Content (W/W): > 0.0 - < 0.1%
Synonym: Octamethylcyclotetrasiloxane
4. First-Aid Measures
General advice:
Immediately remove contaminated clothing.
If inhaled:
If difficulties occur after vapour/aerosol has been inhaled, remove to fresh air and seek medical
attention.
If on skin:
Remove contaminated clothing. Wash affected areas thoroughly with soap and water. If irritation
develops, seek medical attention.
If in eyes:
Immediately wash affected eyes for at least 15 minutes under running water with eyelids held open,
consult an eye specialist.
If swallowed:
Immediately rinse mouth and then drink 200 - 300 ml water, do not induce vomiting, seek medical
attention. Never induce vomiting or give anything by mouth if the victim is unconscious or having
convulsions.
Symptoms: Information, i.e. additional information on symptoms and effects may be included in the
GHS labeling phrases available in Section 2 and in the Toxicological assessments available in
Section 11.
Note to physician
Treatment: Treat according to symptoms (decontamination, vital functions), no
known specific antidote.
Safety Data Sheet
FoamStar SI 2292 NC
Revision date : 2022/05/11 Page: 4/11
Version: 6.0 (30587205/SDS_GEN_US/EN)
5. Fire-Fighting Measures
Extinguishing media
Further information:
The degree of risk is governed by the burning substance and the fire conditions. Contaminated
extinguishing water must be disposed of in accordance with official regulations.
Environmental precautions
Do not discharge into drains/surface waters/groundwater.
Further information on storage conditions: Keep container tightly closed and dry; store in a cool
place.
Safety Data Sheet
FoamStar SI 2292 NC
Revision date : 2022/05/11 Page: 5/11
Version: 6.0 (30587205/SDS_GEN_US/EN)
Protect from temperatures above: 40 °C
Hand protection:
Chemical resistant protective gloves
Eye protection:
Tightly fitting safety goggles (chemical goggles). Wear face shield if splashing hazard exists.
Body protection:
Impermeable protective clothing
Form: liquid
Odour: solvent-like
Odour threshold: No applicable information available.
Colour: light yellow
pH value: not applicable
pour point: < -40.0 °C
boiling temperature: approx. 170 °C
The statements are based on the
properties of the individual
components.
Sublimation point: No applicable information available.
Flash point: 63 °C (DIN 51755)
Flammability: Combustible Liquid
Lower explosion limit: For liquids not relevant for
classification and labelling. The lower
explosion point may be 5 - 15 °C
below the flash point.
Upper explosion limit: For liquids not relevant for
classification and labelling.
Autoignition: not determined
Vapour pressure: not determined
Safety Data Sheet
FoamStar SI 2292 NC
Revision date : 2022/05/11 Page: 6/11
Version: 6.0 (30587205/SDS_GEN_US/EN)
Density: 0.89 - 0.93 g/cm3 (DIN 51757)
( 20 °C)
Relative density: 0.89 - 0.93
( 20 °C)
Vapour density: not determined
Partitioning coefficient n- not applicable for mixtures
octanol/water (log Pow):
Self-ignition Keep away from heat, spark, and
temperature: open flames.
Thermal decomposition: No decomposition if stored and handled as
prescribed/indicated.
Viscosity, dynamic: 5.0 - 15.0 mPa*s (DIN 53015)
( 20 °C)
Viscosity, kinematic: No applicable information available.
Solubility in water: emulsifiable
Solubility (quantitative): No applicable information available.
Solubility (qualitative): soluble
solvent(s): organic solvents,
Molar mass: No applicable information available.
Evaporation rate: not determined
Reactivity
No hazardous reactions if stored and handled as prescribed/indicated.
Oxidizing properties:
not fire-propagating
Chemical stability
The product is chemically stable.
Conditions to avoid
Avoid all sources of ignition: heat, sparks, open flame.
Incompatible materials
None known during use and storage if used according to instructions.
Decomposition products:
No hazardous decomposition products if stored and handled as prescribed/indicated.
Thermal decomposition:
No decomposition if stored and handled as prescribed/indicated.
Acute Toxicity/Effects
Acute toxicity
Assessment of acute toxicity: May be harmful if swallowed.
Oral
Type of value: LD50
Value: > 300 - 2,000 mg/kg
The product has not been tested. The statement has been derived from the properties of the
individual components.
Inhalation
Type of value: LC50
Species: rat
Exposure time: 4 h
not determined
Dermal
Type of value: LD50
Species: rat
not determined
Irritation / corrosion
Assessment of irritating effects: Irritating to eyes. Causes skin irritation. Substance can be absorbed
through the skin in harmful amounts.
Skin
Species: rabbit
Result: Irritant.
The product has not been tested. The statement has been derived from the properties of the
individual components.
Eye
Species: rabbit
Result: Irritant.
The product has not been tested. The statement has been derived from the properties of the
individual components.
Sensitization
Assessment of sensitization: There is no evidence of a skin-sensitizing potential. The product has
not been tested. The statement has been derived from the properties of the individual components.
Aspiration Hazard
No aspiration hazard expected.
Chronic Toxicity/Effects
Genetic toxicity
Assessment of mutagenicity: Based on the ingredients, there is no suspicion of a mutagenic effect.
Carcinogenicity
Assessment of carcinogenicity: The whole of the information assessable provides no indication of a
carcinogenic effect.
Reproductive toxicity
Assessment of reproduction toxicity: Based on the ingredients, there is no suspicion of a toxic effect
on reproduction.
Teratogenicity
Assessment of teratogenicity: Based on the ingredients, there is no suspicion of a teratogenic effect.
Other Information
Skin resorption hazard. The product has not been tested. The statement has been derived from the
properties of the individual components.
Toxicity
Aquatic toxicity
Assessment of aquatic toxicity:
The product has not been tested. The statement has been derived from the properties of the
individual components.
Toxicity to fish
LC50 (96 h) > 100 mg/l, Fish
The product has not been tested. The statement has been derived from the properties of the
individual components.
Aquatic invertebrates
EC50 > 100 mg/l
The product has not been tested. The statement has been derived from the properties of the
hydrolysis products.
Toxicity to microorganisms
EC0: > 100 mg/l
The product has not been tested. The statement has been derived from the properties of the
individual components.
Bioaccumulative potential
Mobility in soil
Additional information
Container disposal:
Dispose of in a licensed facility. Recommend crushing, puncturing or other means to prevent
unauthorized use of used containers.
Sea transport
IMDG
Not classified as a dangerous good under transport regulations
Air transport
IATA/ICAO
Not classified as a dangerous good under transport regulations
Federal Regulations
Registration status:
Safety Data Sheet
FoamStar SI 2292 NC
Revision date : 2022/05/11 Page: 10/11
Version: 6.0 (30587205/SDS_GEN_US/EN)
Chemical TSCA, US released / listed
EPCRA 311/312 (Hazard categories): Refer to SDS section 2 for GHS hazard classes applicable
for this product.
EPCRA 313:
CAS Number Chemical name
111-76-2 2-butoxyethanol
State regulations
State RTK CAS Number Chemical name
NJ 111-76-2 2-butoxyethanol
PA 111-76-2 2-butoxyethanol
WARNING: This product can expose you to chemicals including ETHYLENE GLYCOL (INGESTED),
which is known to the State of California to cause birth defects or other reproductive harm. For more
information, go to www.P65Warnings.ca.gov.
We support worldwide Responsible Care® initiatives. We value the health and safety of our
employees, customers, suppliers and neighbors, and the protection of the environment. Our
commitment to Responsible Care is integral to conducting our business and operating our facilities in
a safe and environmentally responsible fashion, supporting our customers and suppliers in ensuring
the safe and environmentally sound handling of our products, and minimizing the impact of our
operations on society and the environment during production, storage, transport, use and disposal of
our products.