Professional Documents
Culture Documents
Manual de Taller de Nissan Frontier 2008
Manual de Taller de Nissan Frontier 2008
1
MAINTENANCE
SECTION MA
MAINTENANCE
B
E
CONTENTS
SERVICE INFORMATION ............................ 2 Periodic Maintenance (For Europe) .......................... 3 F
Periodic Maintenance (For Russia) .......................... 8
MODIFICATION NOTICE .................................... 2
Major Modification Item ............................................. 2 RECOMMENDED FLUIDS AND LUBRI-
G
CANTS .............................................................. 12
PERIODIC MAINTENANCE ................................ 3 Fluids and Lubricants ..............................................12
H
MA
MA-1
MODIFICATION NOTICE
< SERVICE INFORMATION >
SERVICE INFORMATION
MODIFICATION NOTICE
Major Modification Item INFOID:0000000005852826
• The maintenance schedules for Europe and Russia have been revised.
• The specifications of recommended fluids and lubricants for engine oil have been revised.
MA-2
PERIODIC MAINTENANCE
< SERVICE INFORMATION >
PERIODIC MAINTENANCE
A
Periodic Maintenance (For Europe) INFOID:0000000005852827
The following tables show the normal maintenance schedule. Depending upon weather and atmospheric con- B
ditions, varying road surfaces, individual driving habits and vehicle usage, additional or more frequent mainte-
nance may be required.
Periodic maintenance beyond the last period shown on the tables requires similar maintenance.
C
ENGINE AND EMISSION CONTROL MAINTENANCE (2WD YD25DDTi DIESEL ENGINE)
Abbreviations: R = Replace, I = Inspect: Correct or replace if necessary, D = Check filter and drain water, [ ] = At the specified mileage only
MA-3
PERIODIC MAINTENANCE
< SERVICE INFORMATION >
MAINTENANCE OPERATION MAINTENANCE INTERVAL
km x 1,000 20 40 60 80 100 120 Reference page
Perform at a kilometer (mile) or month in-
(Miles x 1,000) (12) (24) (36) (48) (60) (72)
terval, whichever comes first.
Months 12 24 36 48 60 72
Brake booster vacuum hoses, connections
I I I MA section*
& check valve
Power steering fluid & lines (For level &
I I I I I I MA section*
leaks)
Manual transmission gear oil (For level &
I I I [R] I I MA section*
leaks or replace)
Transfer fluid (For level & leaks) I I I I I I MA section*
Differential gear oil (For level & leaks or re-
I I R I I R MA section*
place)
Limited-slip differential (LSD) gear oil (For
I I R I I R MA section*
level & leaks or replace)
Steering gear & linkage, axle & suspension
parts, propeller shaft, drive shafts, & ex- I I I I I I MA section*
haust system
Brake pads, rotors & other brake compo-
I I I I I I MA section*
nents
Brake linings, drums & other brake compo-
I I I I I I MA section*
nents
Foot brake, parking brake & clutch (For BR section*
I I I I I I
free play, stroke & operation) CL section*
Greasing point of steering linkage, propel- See
L L L L L L MA section*
ler shaft & suspension NOTE (1)
MA-4
PERIODIC MAINTENANCE
< SERVICE INFORMATION >
Maintenance operation: Inspect = Inspect and correct or replace as necessary.
Mainte- A
Reference
Driving condition Maintenance item nance op- Maintenance interval
page
eration
Every 30,000 km (18,000 B
A . . . . . . . . . . Air cleaner filter Replace
miles) or 18 months MA section*1
MA-5
PERIODIC MAINTENANCE
< SERVICE INFORMATION >
NOTE:
• (1) Periodic maintenance is not required. However, if valve noise increases, check valve clearance.
• (2) Replace the drive belts if found damaged.
• (3) Never use API CG-4 grade oil.
• (4) Oil filter element assembly and O-ring seal are replacement parts.
• (5) If engine power decreases, black exhaust smoke is emitted or engine noise increases, perform this maintenance item.
• Maintenance items with “ ” should be performed more frequently according to “Maintenance under severe driving condi-
tions”.
MA-6
PERIODIC MAINTENANCE
< SERVICE INFORMATION >
• Maintenance items with “ ” should be performed more frequently according to “Maintenance under severe driving condi-
tions”. A
MAINTENANCE UNDER SEVERE DRIVING CONDITIONS (4WD YD25DDTi DIESEL ENGINE)
The maintenance intervals shown on the preceding pages are for normal operating conditions. If the vehicle is
mainly operated under severe driving conditions as shown below, more frequent maintenance must be per- B
formed on the following items as shown in the table.
MA-7
PERIODIC MAINTENANCE
< SERVICE INFORMATION >
• Brake pads and rotors
• Brake lining and drums
• Brake lines and hoses
• Wheel bearing grease
• Free-running hub grease
• Differential, transfer and manual transmission gear oil
• Steering linkage
• Propeller shaft and drive shafts
• Air cleaner filter
• Clutch housing (Check water entry.)
Periodic Maintenance (For Russia) INFOID:0000000005852828
The following tables show the normal maintenance schedule. Depending upon weather and atmospheric con-
ditions, varying road surfaces, individual driving habits and vehicle usage, additional or more frequent mainte-
nance may be required.
Periodic maintenance beyond the last period shown on the tables requires similar maintenance.
ENGINE AND EMISSION CONTROL MAINTENANCE (YD25DDTi DIESEL ENGINE)
NOTE:
• Maintenance items with “ ” should be performed more frequently according to “Maintenance Under Severe Driving Condi-
tions”.
• (1) First replace at 80,000 km (48,000 miles)/48 months, then every 40,000 km (24,000 miles)/24 months. Perform “I” (Check-
ing the mixture ratio and correcting the mixture ratio if necessary) every 20,000 km (12,000 miles)/12 months.
• (2) If valve noise increases, check valve clearance.
• (3) If engine power decreases, black exhaust smoke is emitted or engine noise increases, check injection nozzles and if nec-
essary, replace fuel injector assembly.
• *: Refer to SM1E-D22FG1.
MA-8
PERIODIC MAINTENANCE
< SERVICE INFORMATION >
Abbreviations: I = Inspect and correct or replace as necessary, R = Replace, L = Lubricate, T = Tighten.
Mainte-
Reference
Driving condition Maintenance item nance Maintenance interval
page
operation
A . . . . . . . . . Air cleaner filter Replace More frequently MA section*1
A . . . . . . . . . Cyclone pre-air filter Inspect More frequently MA section*1
Every 5,000 km (3,000
A B C D . . . . . . Engine oil & engine oil filter Replace
miles) or 6 months MA section*1
MA-10
PERIODIC MAINTENANCE
< SERVICE INFORMATION >
• Differential gear oil, transfer fluid and manual transmission gear oil
• Steering linkage A
• Propeller shaft and front drive shafts
• Air cleaner filter
• Clutch housing (Check water entry)
B
MA
MA-11
RECOMMENDED FLUIDS AND LUBRICANTS
< SERVICE INFORMATION >
RECOMMENDED FLUIDS AND LUBRICANTS
Fluids and Lubricants INFOID:0000000005852829
Capacity (Approximate)
Recommended Fluids/Lubricants
Liter Imp measure
With oil filter 3.6 3-1/8 qt • For Europe
2WD
Without oil filter 3.3 2-7/8 qt Genuine NISSAN engine oil*1
API grade SL or SM*1
With oil filter 4.1 3-5/8 qt
ILSAC grade GF-3 or GF-4*1
KA24DE ACEA A1/B1, A3/B3, A4/B4, A5/B5, C2 or C3*1
4WD • Except for Europe
Without oil filter 3.8 3-3/8 qt Genuine NISSAN engine oil*1
API grade SE, SF, SG, SH, SJ, SL or SM*1
ILSAC grade GF-1, GF-2, GF-3, GF-4 or SG+*1
With oil filter 5.6 4-7/8 qt • For Europe
2WD YD without common rail:
Without oil filter 5.3 4-5/8 qt
YD25DDTi Genuine NISSAN engine oil*1
With oil filter 4.3 3-3/4 qt
4WD API CF-4*1, *2
Without oil filter 4.0 3-1/2 qt ACEA B1*1
With oil filter 6.7 5-7/8 qt Global DHD-1*1
ZD30DDT YD with common rail:
Without oil filter 6.2 5-1/2 qt
Genuine NISSAN engine oil*1
With oil filter 6.0 5-1/4 qt
TD27 API CF-4*1, *2
Without oil filter 5.3 4-5/8 qt ACEA B1, B3, B4 or B5*1
Engine oil With oil filter 7.2 6-3/8 qt • Except for Europe
(Refill) 2WD TD and QD:
Without oil filter 6.5 5-3/4 qt
Genuine NISSAN engine oil*1
With oil filter 6.9 6-1/8 qt API CD, CE, CF or CF-4*1, *2
JASO DH-1*1
Global DHD-1*1
ZD:
Genuine NISSAN engine oil*1
API CE, CF or CF-4*1, *2
JASO DH-1*1
QD32 Global DHD-1*1
YD without common rail:
4WD
Without oil filter 6.2 5-1/2 qt Genuine NISSAN engine oil* 1
API CF-4*1, 2
ACEA B1*1
Global DHD-1*1
YD with common rail:
Genuine NISSAN engine oil*1
API CF-4*1, *2
JASO DH-1*1
ACEA B1, B3, B4 or B5*1
Automatic transmission fluid RE4R01A 8.1 7-1/8 qt Genuine NISSAN Matic D ATF recommended*3
Front R180A 1.3 2-1/4 pt • Front
Genuine NISSAN Differential Oil Hypoid Super
Differential gear oil GL-5 80W-90 or API GL-5, Viscosity SAE 80W-
(Without limited slip dif- C200 1.3 2-1/4 pt 90
ferential) Rear
H233B 2.8 4/7/8 pt • Rear
API GL-5*1
Differential gear oil C200 1.3 2-1/4 pt Genuine NISSAN Differential Oil Hypoid LSD GL-5
(With limited slip differential) H233B 2.8 4-7/8 pt 80W-90 or equivalent
MA-12
RECOMMENDED FLUIDS AND LUBRICANTS
< SERVICE INFORMATION >
Capacity (Approximate)
Recommended Fluids/Lubricants A
Liter Imp measure
Genuine NISSAN Matic C ATF or API GL-4, Vis-
Transfer gear oil XT10A 2.2 2qt
cosity SAE 75W-90
B
Power steering fluid — — Genuine NISSAN PSF or equivalent*4
For Europe model:
Genuine NISSAN Brake Fluid, or equivalent DOT3
C
Brake and clutch fluid — — or DOT4 (US FMVSS No. 116)*5
Except for Europe model:
Genuine NISSAN Brake Fluid, or equivalent DOT3
D
*1: For further details, see “SAE Viscosity Number”.
*2: Never use API CG-4.
*3: Using fluid other than Genuine NISSAN Matic D ATF will cause deterioration in driveability and automatic transmission durability, and
may damage the automatic transmission, which is not covered by the warranty. E
*4: DEXRONTM VI type ATF may also be used.
*5: Never mix different types of fluids (DOT3 and DOT4).
F
MA
MA-13