Professional Documents
Culture Documents
Specification - GI Wires - MESPL May 2021
Specification - GI Wires - MESPL May 2021
Sr.No. Parameter Specification Measurement Unit Specification as per Standard Test Method /Test Standard
2 Wire Diameter
i C 0.10 Maximum %
ii Mn 0.70 Maximum %
iv P 0.05 Maximum %
v S 0.05 Maximum %
4 Minimum Zinc Coating Mass on the Wire( Zinc Coating process: Hot dip galvanisation)
Page 1 of 2
Zinc Coating Uniformity
a Coating Adhesion No Flakes, No Cracks in the Coating after the Test _ IS 4826-1979 IS 4826-1979
A. a. Labelling Coil shall be labelled with Coil No., Maccaferri Spec. No., Wire Dia., Batch No. and the Weight , as Minimum., on the Metal Tag. Ends of the coil shall be identified appropriately.
Coils shall be properly packed with four metal of plastic strips to avoid the transit damages. Protective cover shall be used to avoid damages to the coating. Wire shall be of very good
a Aesthetics
surface finish & shall be free of high points, cracks, rust & pits, oil and weld joints. Coil shall be free from entanglement and surface irregularities.
MTC of supplier for every lot with above checkpoints. Reports of external laboratory for the GI Wires and Zinc ingots including the manufacturer's TCs shall be provided whenever
b Quality Document required
requested . Frequency of such tests at agreed laboratory shall be at least once in a six months.
Note: 1.If the Test Codes are different, supplier needs to prove the equivalence of the Test Codes to the Codes specified here. 2. For 3.40 mm Wire there are two types, 270 gsm & 300 gsm, all other properties remains same.
Prepared By: M.B.Haval , DGM QA & QS Reviewed & Approved By: Thomas Cherian, GM-QS & Regional Head Quality - ISEAP
Page 2 of 2