Professional Documents
Culture Documents
Asentria Public - 48VDC - Power - Supply - Card - Installation - Guide
Asentria Public - 48VDC - Power - Supply - Card - Installation - Guide
support@asentria.com
( Note: This article was exported to PDF from our Support Wiki. We apologize for any imperfect formatting )
►Instructions
Instructions
1. Remove the knock outs on the outlet box as needed for wiring access through the
outlet box.
2. Strip approx. 1.5" of the outer insulation on one end of the white wire harness. Do not
damage the inner insulation.
3. Clip the black terminal wire 1/2" then strip both inner terminal wires and crimp on the
supplied quick connect terminals.
4. Strip back the outer Insulation approx. 1" on the other end of the harness. Do not
damage the inner insulation.
5. Strip the inner wires to 1/4".
6. Run the wires through the Outlet Box and slide the quick connects onto the horizontal
quick connect tabs A and B.
7. Install the other end to Contact Closure points (Red to + and black to -) on your
SiteBoss using the screw down terminals.
8. Run a wire through the outlet box and connect the red wire on the Seco-Larm to a
Relay point on your SiteBoss using the screw down terminals. The butt splice supplied
can be used to extend the length of the wire from the Seco-Larm relay.
9. Connect the second relay point on the SiteBoss to the positive power supply terminal.
10. Running the wires through the outlet box, connect the Blue wire with the red quick
connect to the vertical quick connect tab C.
11. Connect the other end of the blue wire to the minus power terminal.
12. Screw the outlet plate to the outlet box using the supplied 6-32 screws and install the
box to the wall location.
History Table
Date Description
10 Nov 20 Added History Table
10 Nov 20 Updated wiki formatting