Professional Documents
Culture Documents
Stas 8600-79
Stas 8600-79
01
1 GENERAL
1.1 The present standard specifies the system of tolerance in non-industrial, industrial constructions and
agriculture buildings and namely the classes of precision and the values of the basic tolerances corresponding to these
classes, depending on the dimensional quantities of the elements of constructions or of the constructions.
1.3 The values of the tolerances prescribed in the designs of execution have to correspond to the values of basic
tolerances of the systems of tolerances from the present standard and will be expressed either by specifying them, or by
specifying of the corresponding class of precision.
1.4 The system of tolerances is used in the normative technical documents, in totality or only partially, depending
on the specificity of the specifications from these documents.
© ASRO Entire or partial multiplication or use of this standard in any kind of publications and by any means (electronically, mechanically,
photocopy, micromedia etc.) is strictly forbidden without a prior written consent of ASRO
STAS 8600-79 -2-
1.5 The terminology used in the present standard is according to STAS 7009-79.
2 SYSTEM OF TOLERANCES
2.1 The values of the basic tolerances correspond to the values of the array of numbers Ra 5, completed with
values of the array Ra 10, according to STAS 75-72 and STAS 283-69.
2.2 The system of tolerances in constructions, depending on the dimensional quantities of the elements of
constructions or of the constructions, is according to the table.
NOTE – The values 0.24; 2.4 and 24 replace the values 0.25; 2.5 and 25 from the arrays Ra 5 and Ra 10 in order to easy
the expression of the respective tolerance by symmetrical limit deviations.
2.3 The dimensional quantity, in rapport with which is specified the tolerance, depending on the type of the
geometrical characteristics at which it refers, representing:
- the dimension, for dimension characteristics;
- the length of reference, for characteristics of shape and position of the profiles or of surfaces;
- any dimension of the reference surface, for characteristics of surface shape.
2.4 For geometrical characteristics of the same element can be chosen tolerances corresponding to some different
classes of precision, determined depending on the consequences which result from it, on the possibilities of mounting-
assembling of the element and of the exploitation of the construction.