Professional Documents
Culture Documents
Faren Buildcon Plasto Ready
Faren Buildcon Plasto Ready
5 W X 55 H CM
TM
PLASTO READY - PR
USE
Plastering Solution
PLASTO READY
NO
Faren BuildCon
Faren Buildcon
TM
HOOKS Faren BuildCon EAS
PR
TO
PLASTO READY BUILD
PRODUCTS
Plastering Solution
PR
Faren Buildcon PLASTO READY - PR is a cement-based, plastering mortar for application over masonry walls, RCC columns,
PLASTO READY beams and ceiling areas. It provides strong surface suitable for all types of final finishing applications. Highly
recommended over well-prepared walls with maximum thickness of plastering up to 15 mm in single layer.
PLASTO READY - PR
Mix only the required quantity of material which can be consumed within the 1 hour pot life and do not add more water than
the prescribed water ratio.
Allow the mix to stand for 2 minutes to mature and then mix it again before use
CONFORMS TO IS 1661-1972, 2250-1981, 2402-1963
SURFACE PREPARATION
Prepare the surface before the application of Faren Buildcon PLASTO READY - PR by removing oil, bond inhibiting agents,
dirt, dust and laitance.
Clean the surface using a wire brush and water jet. Pre-wet the surface before the application of Faren Buildcon PLASTO READY - PR
It is advisable to roughen the concrete surface or apply. Faren Buildcon SEAL & DRY 5 PLUS as a bonding agent
over the concrete surface to have the required adhesion.
APPLICATION
Apply Faren Buildcon PLASTO READY - PR using mortar trowel / spatula / aluminum float as done in conventional
plaster applications.
For achieving higher thickness above 15 mm, it is recommended to apply multiple layers.
PRECAUTIONS
Application on external walls in windy/high temperature conditions may result in faster drying of the product which can
cause shrinkage related issues. Do not use if temperature is likely to drop below 5°C or exceed 50°C
Use of gloves is recommended at the time of application and prevent direct contact with skin and eyes. !
In case of contact, wash with clean water immediately.
CURING
In normal climatic condition, Faren Buildcon PLASTO READY - PR requires 2-3 times daily curing for 2-3 days after
24 hours of application.
PR
5
For any further information, kindly refer product technical data sheet.
PLASTO READY
PP
*Shelf life: Best before 12 months from manufacturing date.
Faren BuildCon
Plastering Solution
Manufactured & Marketed By: Faren Buildcon
Block Sarve No. 411, Sarodhi Village, National Highway No. 48, Valsad, Gujarat - 396171
For any consumer complaints please contact registered office address
SUPERIOR QUALITY READY TO USE and customer care number:
SAVES TIME AND LABOUR LESS CURING
Ref No.: Mfg. Date: Net Weight MRP ` (incl. of all taxes)
TM
40 kg
TM
FAREN BUILDCON
MANUFACTURERS IMPORTERS DISTRIBUTORS OF CONSTRUCTION MATERIALS
TM
FAREN BUILDCON
MANUFACTURERS IMPORTERS DISTRIBUTORS OF CONSTRUCTION MATERIALS
TM