Professional Documents
Culture Documents
MCQ'S: Civil Engineering
MCQ'S: Civil Engineering
MCQ'S: Civil Engineering
MCQ’s
Junior Engineer
SSC, RRB, State PSC’s & SSC’s & Other Exams
Telegram & Facebook > search @civilmcqz
Sample SET
Email ⇒ civilengineeringmcqz@gmail.com
© Copyright
All rights are reserved. No part of this book may be reproduced in any form or by any electronic or mechanical
means without permission in writing from the publisher. The publishers have taken all possible precautions in
publishing this book, yet if any mistake has crept in, the publishers shall not be responsible for the same.
CHANDAN’s Guidance will be grateful if you could point out any such error. Your suggestions will be
appreciated.
(a) Has strength less than 10% to 15% 6. The Rankine half oval body MM is subjected
(b) Has more resistance to weathering to the two-dimensional flow having velocity V.
(c) Is more plastic and workable The typical stream line is shown in the following
(d) All of the above diagram. The point A in the diagram shows _____.
Ans. (d)
2. Which of the following is most common (a) Point at which velocity is maximum
alternative to cement in concrete? (b) Separation point
(c) Stagnation point
(a) Slag
(d) Stall point
(b) Fly ash
Ans. (c)
(c) Asphalt
(d) Lime
Ans. (d)
(b) Thrice the diameter value shall not exceed by weight _____.
(c) Four times the diameter
(d) Five times the diameter (a) 0.2
(b) 0.25
Ans. (a)
(c) 0.3
18. In an optical square, the angle between the (d) 0.45
first incident ray and the last reflected ray is ____. Ans. (c)
(a) 0.05
(b) 0.15
(c) 0.25
(d) 0.35
Ans. (b)
(a) 100 t compressive
(b) 100 t tensile 32. Which of the following property of bitumen
(c) Zero
47. The underground structure in the form of a Which of these statements is/are correct?
circular or rectangular tank for the purpose of
(a) Only 1
admitting sewage into it from the intercepting
(b) 1 , 2 and 4
chamber is called _____.
(c) 1, 3 and 4
(a) Septic tank (d) 1, 2, 3 and 4
(b) Cess pool Ans. (d)
(c) Privy pit
(d) Soak pit 51. Calculate the total quantity (cubic meter) of
Ans. (b) the coarse aggregate required for an isolated
rectangular footing of size 3 m × 2 m, if 1 : 2 : 4
cement concrete is used. The depth of the
footing is 600 mm.
(a) 2.05
(b) 2.46
(c) 3.16
48. A procedure of actual costing and valuing an
(d) 3.82
item of work on the basis of labourers and
materials required is _____. Ans. (c)
54. Proof resilience is the maximum energy 58. If the initial void ratio of the soil is 0.60, and
stored at _____. it is consolidated up to 55% to reduce the void
ratio to 0.45. Determine the minimum void ratio
(a) Limit of proportionality up to which it can be further compressed _____.
(b) Elastic limit
(c) Plastic limit (a) 0.20
(d) None of the above (b) 0.33
Ans. (b) (c) 0.40
(d) Insufficient Data
Ans. (b)
(a) Proof stress of the material 68. If the net amount of irrigation is 8 cm and
(b) Loading conditions field efficient is 75%, the gross amount of water
(c) Poisons ratio to be applied to the field will be _____.
(d) Cross sectional geometry
Ans. (d) (a) 10.66 cm
(b) 8.75 cm
(c) 10.66 mm
(d) 8.75 mm
Ans. (a)
86. The hydraulic gradient line of a flowing fluid 90. The rigid frame shown in figure below
is represented by _____. carries a load of 10 kN at point P. If the girder PQ
is displaced through a horizontal displacement
(a) Pressure head + kinetic head of Δ, then the horizontal reaction at joint R will
(b) Kinetic head + datum head be _____.
(c) Pressure head + datum head
(d) Pressure head + kinetic head + datum
head
Ans. (c)
6𝐸𝐼∆
(a) 𝐿³
9𝐸𝐼∆
(b) 𝐿³
(a) p
(b) p/2
(c) zero
(d) none of the above
Ans. (a)