Professional Documents
Culture Documents
Preset Adjustment
Preset Adjustment
Preset Adjustment
・Limit direction
・Motor direction
・Compen type
[Limit direction]
When the origin return operation (origin = ON) is performed, the compensator moves to
the origin remid switch. Set to move.
※Compen when the compenroll is moving in the direction of the origin limit switch Make
sure that the value in the real position is decreasing. If the value of the actual position of
the compen increases, the A phase and B phase of the encoder signal line Please
replace.
[Motor direction]
“Set in the opposite direction to the "remid direction"。
[Compen type]
Set the paper thread of the competition roll
原点 LS 原点 LS
原点 LS 原点 LS
Type A Type B Type C Type D
[PS TYPE]
Set the constant of the preset
Calculation of preset constants ... [Primary C1 / MIN D1_s] Measure the path length
between units and calculate internal data.
1)Move the compen to the origin position.
2)Set the cylinder and lower the impression cylinder with the base paper stretched.
3)Mark the nip point and measure the pathlength. *
Path length is measured with two types of cylinders of different sizes.
「a」~「b」Measure length
←Compen moves to the origin position
mark「a」 mark「b」
4)Internal data is calculated from the actual measurement result of the path length
between units.
When the measurement result of the path length is as follows
・Cylinder size1「300.0mm」Path length1=7140.0mm
・Cylinder size2「600.0mm」Path length2=7080.0mm
[1次 C1]calculation
C1 =(Path length1-Path length2)/(Cylinder size1-Cylinder size2)
=(7140-7080)/(300-600)
=-0.2
[MIN D1_s]calculation
D1_s = Path length1 - C1 × Cylinder size1
As a result of starting printing and registering, the "calculated value" and "actual
position" are When it becomes as follows.
MIN D1_s=7200.0
Calculated values Real position
315.5 328.0