Professional Documents
Culture Documents
Discussion Part B
Discussion Part B
Discussion Part B
When the resistors were manufactured, the measured value of resistors were deviated from nominal
values.
Therefore this resistors were given a tolerance to skip this problems by manufactures when use this
resistors .
The accuracy of the readings the take were depended on how well the instrument was calibrated.
The internal resistance of DMM was impacted to the real value of resistance.
The resistance range in 3.267 to 3.333 resistor, the resistance value is 3.3 OHM from color band.
The Real value of resistor was not deviated only manufacture fault.
The bad connection with resistor ends and DMM ropes was caused to deviation values.
The resistance rage in 0.99 to 1.01 resistor, the resistance value is 1 OHM from color code and its
measured value is 1.1 OHM in the ………………. Table.
The measured value was exceeded the maximum value of this resistor(1.1 OHM)
In addition to that lab temperate was affected to deviation the resistance. It depend on this
equation……………….