Professional Documents
Culture Documents
Honda CR-V 2012-2016 V3G.1.2a
Honda CR-V 2012-2016 V3G.1.2a
Honda CR-V 2012-2016 V3G.1.2a
EASE
FOR
2012-2016 Honda CR-V
This power lift gate kit for Honda CRV support
automatic trunk open/close control by using 1) remote
keyfob 2) dashboard button 3) gate button 4) Foot
sensor – optional
NOTICE
ATTENTION:
1
PART LIST
2
Trim Spanner Cable Route Electric
Remover Puller Tape
x1 x1 x1 x1
REMARK: Pictures for reference only, they may look different or not
reflect actual product while products being updated time to time.
Autoease keep the right to update appearance & design without
notifications.
SCHEME
CONTROL BOX
3
① CAN Bus
② N/A
③ SD Card Slot
④ Power
⑤ Left Strut
⑥ Right Strut
⑦ Latch Motor
⑧ Lock Assembly
INSTALLATION STEPS
4
3. Remove main trunk panel
5
Pry the trim panel in the picture as below
6
6. Remove the cover panel indicated by the circle in the
picture as below, remove door handle first
7
8. Remove original gas spring & studs
9. Install our door bracket per picture, then install door stud
& washer per picture (note door stud is shorter than car
body stud)
8
Install our car body stud & washer
9
Routing strut cable picture, after removing taillights (both left
and right).
10
Ground our GND wire to a screw nearby control box
12. Replace original latch striker to ours for soft close, fix with
our KM8 screws
13. Route front button cable, power cable and yellow unlock
cable to driver’s position, NOTE place control box (ECU)
in left side of trunk
11
Route lock adapter cable and rear button cable to door panel
12
16. Drill a hole to install our front button, picture for
reference.
13
18. Drill a hole to install our rear button, picture for reference.
14
2. How to setup tailgate height?
15
1) check front button wires connection
2) check lock adapter (status) signal
3) update firmware
16