To install Keil uVision IDE and configure it for the FRDM-KL25Z microcontroller board, one must: download and run the uVision setup, select the MKL25Z128xxx4 device and FRDM-KL25Z board in the IDE, and install all recommended packs and PEmicro USB debug drivers to interface the board.
To install Keil uVision IDE and configure it for the FRDM-KL25Z microcontroller board, one must: download and run the uVision setup, select the MKL25Z128xxx4 device and FRDM-KL25Z board in the IDE, and install all recommended packs and PEmicro USB debug drivers to interface the board.
To install Keil uVision IDE and configure it for the FRDM-KL25Z microcontroller board, one must: download and run the uVision setup, select the MKL25Z128xxx4 device and FRDM-KL25Z board in the IDE, and install all recommended packs and PEmicro USB debug drivers to interface the board.
To install Keil uVision IDE and configure it for the FRDM-KL25Z microcontroller board, one must: download and run the uVision setup, select the MKL25Z128xxx4 device and FRDM-KL25Z board in the IDE, and install all recommended packs and PEmicro USB debug drivers to interface the board.
EE2080 Microprocessor Systems: Design and Interfacing Laboratory
Installation help document: Keil uVision
Step 1:Download μVision IDE by registering in https://www.keil.com/demo/eval/arm.htm
Step 2: Run the setup file to complete the installation.
Step 3: On successful installation, you will see a ‘Pack installer’ window. Click OK.
Step 4: Select Devices→NXP→KL2x→MKL25Z128xxx4
Step 5: Select Boards→FRDM-KL25Z → Update/Install all the packs which are shown on the right side of the window.
Step 6: Download PEmicro debug driver.
It is necessary to install debug drivers to interface the FRDM KL25Z board with the system. We will be using PEmicro debug interface. Download the Windows USB drivers for the same from http://www.pemicro.com/opensda/. The download link will be obtained through e-mail once provided.