Configuration

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 1

Daylight (EN 410) Solar Energy (EN 410) Thermal

Conductivity
Configuration
Reflectance Reflectance Direct Reflectance (U value)
Transmittance Absorption Solar Factor Shading W/m²K (EN 673)
Outdoor Indoor Transmittance Outdoor
% % % Coefficient
% % % %

6 mm Şişecam Clear Float Glass + 1.14 mm PVB + 6 mm Şişecam Clear Float Glass 87 8 8 68 7 25 74 0.85 5.3

8 mm Şişecam Clear Float Glass + 1.14 mm PVB + 8 mm Şişecam Clear Float Glass 85 8 8 64 6 29 71 0.82 5.3

Sisecam Glass performances are calculated with WinSLT.


“Daylight” and “Solar Energy” properties are calculated using spectral measurements in compliance with EN 410:2011.
“U-value” is calculated according to EN 673:2011. The emissivity measurements used for calculations are in compliance with EN 673:2011 (Annex A) and EN 12898:2019.
Thermal stresses or building codes may require the use of heat-treated glass. This document is not an evaluation of the risk of glass breakage from thermal stresses. Please contact Sisecam Flat Glass to ensure the correct form of glass to be supplied for the structure.
Glazing units designed above are assumed to be insulated unit and have not been tested. All tests for the systems should be carried out in accordance with EN ISO 104-3 and has to be up to date.
Data on acoustic parameters such as “Weighted Reduction (Rw)” and “Spectrum Adaption Terms C / Ctr” are specified based on estimations determined as the best result for this glazing composition and have not been tested. Perfo rmance on site, can be different related to the sizes of the
glazing, frame design, noise sources etc.
Failure of compliance may generally deviate as high as +/- 2 dB, nevertheless greater deviation may also occur. Accuracy of C and Ctr depends on measured sound spectrum of the tested material.
Sisecam Flat Glass cannot be held responsible for any deviations between the presented data and the conditions on the site. This document is for informational purposes only. Technical and other data are based on information available at the time of preparation of this document and are
subject to change by Sisecam Flat Glass without notice.

2.11.2021

You might also like