Professional Documents
Culture Documents
Exp2 1
Exp2 1
Exp2 1
ABSTRACT
Sieve analysis often referred to as the "grading test," consists of the following steps to
determine the grading of macroaggregates and the grading of coarse aggregate and a mixture of
fine aggregate and coarse aggregate. The number of particles held in each sieve This is achieved.
Sieve analysis is a method for determining the particle size distribution of macroscopic particle
size granules. This experiment tackles the grading of the aggregates that were tasked for the
researchers to get the following objectives that are needed in this experiment.
AIM
To determine the grade of aggregates through ASTM C136.
INTRODUCTION/BACKGROUND
The sieve analysis, often known as the "Gradation Test," consists of the following step
determining the particle size distribution of tiny aggregates and determining the particle size
distribution of coarse aggregates as well as fine and coarse aggregate blends Pouring an aggregate
sample through a series of smaller sieves and weighing the number of particles retained in each
sieve accomplishes this.
Sieving may be used when selecting media for blast cleaning. Ease of use, low investment
cost, accurate results in a reasonable amount of time, and the ability to separate particle size
fractions are some of the benefits of sieving analysis. In places where there is no electricity,
common manual sieving methods are often used to distinguish between large and small particles
in the field. Mechanical sieving, on the other hand, is mainly used in the laboratory to ensure the
quality of the product. There are two types of mechanical sieving: horizontal movement sieving
and vertical movement sieving, which are classified according to the sieving movement used. The
throw-action sieving or vibratory sieving methods are other names for the vertical movement
sieving method. When particles are in a dry state, the dry sieving method is most used. When the
particles in question are already wet or in a suspension, the wet sieving method is typically used.
RESULTS AND DISCUSSION
For this experiment, we can clearly see that This test method is generally used to determine the
grade of materials that are being used as aggregates or that have been recommended for use as
aggregates. The findings are utilized to determine if the particle size distribution complies with
applicable specification criteria, as well as to provide data for quality control of the manufacture
of various aggregate products and aggregate-containing mixes.
Questions
CONCLUSION
The results of the experiment were used to determine the assessment of particle size
Distribution containing specifications and data essential for the manufacture or manufacture of
various aggregates and other mixtures. Based on the comments provided, you may be able to
determine the correct requirements for the required material.
REFERENCES