Professional Documents
Culture Documents
Industrial Electronics
Industrial Electronics
The dual power supply is a type of circuit whose output is consist of positive
voltage and negative voltage.
Schematic Diagram:
R2 C1
10kΩ U1
100µF
7
5
3
RefGND
6
R1 2
LM741 C2
10kΩ
100µF
R3
4
V-
10kΩ
This is the circuit schematic diagram that we created. The operation of this
circuit is as follows: the non-inverting input of the op amp accepts a 6V voltage in the
series resistor at resistor R1. It should be noted that the voltage at the non-inverting
input is the same as the voltage at the inverting input. Because the op amp is set up
as a voltage follower, the output voltage is the same as the inverting input value,
which is 6V. To obtain a positive and negative output voltage, we must regard the op
amp output as ground, which is known as the virtual ground.
In this case, we call our virtual ground as Reference Ground (RefGND). As we
can see in the simulator, the reading of the XMM1 multimeter is -6V, whereas the
reading of the XMM2 multimeter is 5.999V, which is +6V, which is the outputs that
we want.
School of Engineering
INDUSTRIAL ELECTRONICS
Final Project
by
John Lester S. Balbido
Johniel Dondoyano Cimafranca