Professional Documents
Culture Documents
bc2000 k2 Manual
bc2000 k2 Manual
ALARM-
Codes and operating parameters are stored The master code is any 4-6 digits
OPEN
D_IN
COM
GND
If holes are to be drilled before mounting onto a
12V
NO
NC
within the microprocessor and can not be lost wall, check for hidden cables and/or pipes before J3 Setting the working mode:
due to power failure. drilling. Use safety goggles when drilling or ham Do not plug the power supply or transformer into Set valid card only users 3 0 # by card only
the mains until all wiring has been completed Set valid card and PIN users 3 1 # by card and PIN together
mering in cable clips. Set valid card or PIN users 3 2 # by either card or PIN (default)
The BC-2000/K2 can store 1000 users with card Every effort has been made to provide accurate and the front cover secured.
POWER
and 4-6 digits password codes.It has one relay information, however slight variations can occur. Alarm
To set a user in either card or PIN mode ( 3 2 # ) (Default setting)
Current≥200mA DC 12V /3A
output with 3 Amp changeover contacts. We also reserve the right to make changes for -
Exit button
K13 Grey 1 User ID number # PIN #
product improvement at any time Figure 3 ALARM- + + -
The unit has one relay output with 3 Amp Yellow The ID number is any number between 000-999. The PIN is any 4-6
OPEN
digits between 0000-999999 with the exception of 1234 which is
changeover contacts. NOTE: please read these instructions carefully D_IN Brown Door detecting switch
To add a PIN user reserved. Users can be added continuously without exiting from
+12V Red programming mode as follows:
before attempting to install the BC-2000/K2 1 2
GND Black 1 User ID no 1 # PIN # User ID no 2 # PIN #
1 2 2. Specifications 3 4
Blue NO
5 6 NO Electric bolt : NC
3 4 1.Programmable Functions Internal Interface Circuit 7 8 Purple COM Electric strike: NO
-
2 User ID number #
In4007
COM Lock
9 0
Orange + To delete a PIN user
5 6 Relay momentary 1. Alarm output interface (See Figure 1) # NC
NC Users can be deleted continuously without exiting programming mode
7
Relay strike time 2. Electric lock interface (See Figure 2)
8 Pulse mode,Toggle mode BC2000/K2 To change the PIN of a PIN user
Common Power Supply
(This step must be done out of programming mode) * ID number # Old PIN # New PIN # New PIN #
9 0 Change Codes 1 master, 1000 users
ALARM To add a card user (Method 1) 1 Read card #
# Q
K2 BC-2000 POWER
R This is the fastest way to enter cards Cards can be added continuously without
2.Programmable Timers DC 12V /3A
2K NC COM NO +12V GND PUSH using ID number auto generation. exiting programming mode
Door relay time 1-99 seconds Figure 4 Alarm
Figure 1 -