Professional Documents
Culture Documents
KWXTI13500 522 Eng
KWXTI13500 522 Eng
KWXTI13500 522 Eng
Kit Code:
KW XTI 135 0 0
Configuration:
522
Kit composition
Optional:
Application:
VOLVO
FH 420_460_500_540 13L cod. D13K
RENAULT
T 440_480_520 13L cod. DTI13
Standard Setting
Installation
Pict.1
Pict.2
Pict.3
Pict.4
Final Operations
Connect the Rapid module to the wiring.
In case you have purchased the Rapid C08RWC01 switch (optional), connect the 2-pin connector port
male to female port connector wiring Rapid and connect the red wire to the power supply +12V or +24V.
NOTE : Rapid is always on if nothing is connected to the two way connector
Fix the Rapid module and the kit components far from any excessive heat sources.
The variation of the standard pre-set parameters in the RAPID module by the manufacturer must be
agreed with Dimsport technical assistance. Every new calibration must be tested on the vehicle in hard
use conditions.
Notes
Revisione 1.2 4/5 05/03/2019
By
It is possible to commute the RAPID module switch (C08RWC01) from on to off in any conditions of
vehicle use, even though we recommend activating and deactivating the RAPID module when the vehicle is
not working or with a low load.
If the switch is not connected to the special 2-way connector of the RAPID module wiring, the
additional module remains constantly activated.
If you wish to use an alternative switch, please contact the technical assistance.
Warning
CAUTION: An excessive increase in performances could damage the engine or lead to the activation of
the vehicle electronic protections.
Please make sure that the vehicle works properly, namely the engine, before installing the Rapid
module: a performance increase could highlight some potential defects of functioning.
We do not recommend assembling the Rapid module if the engine or the injection system have
already been modified. NB: an excessive increase in performances could lead to damage the engine or to
activate the electronic control unit protections.
Do not turn on the controls board if all the connectors are not connected. If you do not follow this
instruction there would not be any damages, but the control unit would memorize an error.
The Rapid module is designed for 12 to 30 Volt supply voltages, therefore make sure this limit is not
exceeded by checking, before the installation, that the battery, the regulating circuit and the alternator work
properly.
Fix the RAPID module and its parts far from any excessive heat sources.