Download as txt, pdf, or txt
Download as txt, pdf, or txt
You are on page 1of 3

Car Scanner ELM OBD2

Version: 1.97.4/400974/GP
DTC report
Connection profile: Volkswagen OBD-II / EOBDDate: 22/3/2023 10:25:49 �.�.
VIN: WVWZZZ1KZ9P403369
============================
OBD-IIOBD-II
DTCs: 2
----------------------------
P0030 [0x0030]
Heated oxygen sensor (HO2S) 1, bank 1, heater control - circuit malfunction
HO2S Heater Control Circuit Bank 1 Sensor 1
Status: Confirmed
----------------------------
P0299 [0x0299]
Turbocharger (TC)/supercharger (SC) - low boost
Status: Confirmed
============================
19. CAN Gateway
No DTC found.
============================
09. Onboard supply control unit09. Onboard supply control unit
DTCs: 8
----------------------------
2745 [0x0AB9]
Daylight lamp, left-hand headlight; Daytime running light lamp on the left
Status: Pending fault present during this driving cycle, Test is inhibited by other
DTC, Validated and stored in non volatile memory, Validated fault present at time
of request
----------------------------
2746 [0x0ABA]
Daytime running lamp, right-hand headlight; Right daytime running light lamp
Status: Pending fault present during this driving cycle, Test is inhibited by other
DTC, Validated and stored in non volatile memory, Validated fault present at time
of request
----------------------------
0978 [0x03D2]
Left-hand dipped beam bulb-M29; Left-hand low beam headlight bulb-M29
Status: Pending fault present during this driving cycle, Test is inhibited by other
DTC, Validated and stored in non volatile memory
----------------------------
1504 [0x05E0]
License Plate Light-X; License plate light-X
Status: Pending fault present during this driving cycle, Test is inhibited by other
DTC, Validated and stored in non volatile memory, Validated fault present at time
of request
----------------------------
1499 [0x05DB]
Headlight High Beam-M32; Right high beam headlight bulb-M32
Status: Pending fault present during this driving cycle, Test is inhibited by other
DTC, Validated and stored in non volatile memory, Validated fault present at time
of request
----------------------------
1493 [0x05D5]
Front Left Turn Signal Lamp-M5; Front left turn signal lamp-M5
Status: Pending fault present during this driving cycle, Test is inhibited by other
DTC, Validated and stored in non volatile memory
----------------------------
2394 [0x095A]
Front Left Parking Lamp-M1; Front left parking light lamp-M1
Status: Pending fault present during this driving cycle, Test is inhibited by other
DTC, Validated and stored in non volatile memory
----------------------------
1495 [0x05D7]
Left High Beam Headlight Bulb-M30; Left high beam headlight bulb-M30
Status: Pending fault present during this driving cycle, Test is inhibited by other
DTC, Validated and stored in non volatile memory
============================
03. ABS control unit03. ABS control unit
DTCs: 3
----------------------------
0778 [0x030A]
Steering Angle Sensor-G85; Steering angle sender G85
Status: Pending fault present, Test conditions are met, Validated and stored in non
volatile memory, Validated fault present at time of request
----------------------------
0003 [0x0003]
Control block; Control unit
Status: Pending fault present, Test conditions are met, Validated and stored in non
volatile memory, Validated fault present at time of request
----------------------------
1130 [0x046A]
ABS mode; ABS operation
Status: Test is inhibited by other DTC, Validated and stored in non volatile
memory, Validated fault present at time of request
============================
01. Engine control unit
No DTC found.
============================
08. Heater and climate08. Heater and climate
DTCs: 1
----------------------------
9481200 [0x90ABF0]
B10ABF0: Refrigerant pressure, Lower limit not reached
Kaltemitteldruck - unterer Grenzwert unterschritten
Status: Test failed, Confirmed
============================
0D. Slide Door Left (VW TP2.0)
No DTC found.
============================
15. SRS15. SRS
DTCs: 1
----------------------------
9442836 [0x901614]
B101614: Frt.pass. side airbag disabled indicator lamp, Open circuit/short circuit
to ground
passenger-airbag-off display interruption/short to ground
Status: Test failed, Confirmed, Warning indicator requested
============================
16. Steering column
No DTC found.
============================
17. Dashboard
No DTC found.
============================
25. Immobilizer
No DTC found.
============================
42. Driver door electronic equipment42. Driver door electronic equipment
DTCs: 2
----------------------------
0912 [0x0390]
Front Left Power Window Switch-E40; Front left window regulator switch-E40;
Camshaft position sensor => encoder-G301 malfunction
Status: Test is inhibited by other DTC, Validated and stored in non volatile memory
----------------------------
0109 [0x006D]
Indicator repeater lamp in the exterior mirror housing on the driver's side-L131;
Driver's side mirror indicator lamp-L131
Status: Test conditions are met, Test is inhibited by other DTC, Validated and
stored in non volatile memory
============================
44. Power steering
No DTC found.
============================
4F. Body control unit #2 (VW TP2.0)
No DTC found.
============================
52. Front passenger door electronics
No DTC found.
============================
56. Head unit (MMI) (VW TP2.0)56. Head unit (MMI) (VW TP2.0)
DTCs: 1
----------------------------
1042 [0x0412]
The control unit is not encoded; Control unit not coded; Secondary air injection
valve-N112 electrical fault in the circuit
Status: Validated and stored in non volatile memory, Validated fault present at
time of request
============================
62. Rear left door electoronics (VW TP2.0)
No DTC found.
============================
72. Rear right door electronics (VW TP2.0)
No DTC found.
============================
78. Slide Door Right (VW TP2.0)
No DTC found.

You might also like