Professional Documents
Culture Documents
MM32-30-31-02.full - Selector Valve - Practices
MM32-30-31-02.full - Selector Valve - Practices
PSP 601−2
1. Removal/Installation
(Figure 201)
(2) Remove right main landing gear wheel bin (refer to Chapter 53).
WARNING: WEAR EYE PROTECTION WHEN YOU CUT THE LOCKWIRE. WHEN
THE LOCKWIRE IS CUT, PIECES CAN HIT YOUR EYES AND CAUSE
INJURY.
(5) Remove and discard lockwire and disconnect electrical connector (3). Install
protective cover and tie back to prevent contamination from fluid.
(7) Disconnect hydraulic lines (4), (7), (9), (10) and (12). Install protective covers to all
open lines and ports.
(8) Remove three bolts (1) and washers (2), bolt (5) and washer (6).
(10) Remove union (13) and preformed packing (14) from selector valve (15). Discard
preformed packing.
EFFECTIVITY: ALL
(1) Position selector valve complete with T−piece (8) on hydraulic beam and install
three bolts (1) and washers (2), bolt (5) and washer (6). Torque the bolts (1) and (5)
from 20 to 25 lb in (2.26 to 2.82 Nm) (refer to Chapter 20).
(2) Remove protective covers and install union (13) and preformed packing (14).
Torque the union from 161 to 178 lb in (13.42 to 14.83 Nm) (refer to Chapter 20).
(3) Connect hydraulic lines (4), (7), (9), (10) and (12) to their respective ports.
(4) Torque hydraulic lines (4) and (10) from 22.50 to 29.17 lb ft (30.51 to 39.54
Nm)(refer to Chapter 20).
(5) Torque hydraulic line (7) from 100 to 140 lb in (11.30 to 15.81 Nm)(refer to Chapter
20).
(6) Torque hydraulic lines (9) and (12) from 150 to 195 lb in (16.95 to 22.03 Nm) (refer
to Chapter 20).
WARNING: WEAR EYE PROTECTION WHEN YOU CUT THE LOCKWIRE. WHEN
THE LOCKWIRE IS CUT, PIECES CAN HIT YOUR EYES AND CAUSE
INJURY.
(7) Remove protective cover, install electrical connector (3) and lockwire.
(10) Carry out functional test of landing gear extension and retraction system (refer to
EXTENSION AND RETRACTION − MAINTENANCE PRACTICES).
(12) Install right main landing gear wheel bin (refer to Chapter 53).
EFFECTIVITY: ALL
2. Inspection/Check
NOTE: This procedure is applicable only to main landing gear selector valve part
number 61750 and 61750−1.
(2) Send the selector valve to the vendor for replacement of the two aluminum end
caps part number 34629.
EFFECTIVITY: ALL
YMM3230312−01_001
EFFECTIVITY
1 A/C PRE SB 601−0444
2 A/C POST SB 601−0444
EFFECTIVITY: ALL