Professional Documents
Culture Documents
Som 1
Som 1
Calculate the maximum stress induced in a cast iron pipe of external diameter 20 mm, of
internal diameter 10 mm and of length 4 meter when the pipe is supported at its ends and
carries a point load of 70 N at its center.
.A beam 5meter long, simply supported at its ends, and carries a point load W at its center. If
the slope at the ends of the beam is not to exceed 1 o, find the deflection at the center of the
beam.
A mild steel flat 250 mm wide, 20 mm thick and 6 meters long carries an axial pull of 300
kN. If the value of modulus of elasticity is 2x107 N/cm2 and poisson’s ratio 0.30, calculate the
change in length, width, thickness and volume of the flat.
Find the diameter of a circular bar which is subjected to an axial pull of 150 kN, if the
maximum allowable shear stress on any section is 65 N/mm2
The tensile stresses at a point across two mutually perpendicular planes are 130 N/mm 2 and
60 N/mm2. Determine the normal, tangential and resultant stresses on a plane inclined at 30 o
to the axis of the minor stress, by Mohr’s circle method.
A beam 3 meter long, simply supported at its ends, and carries a point load W at its center. If
the slope at the ends of the beam is not to exceed 1 o, find the deflection at the center of the
beam.
At a point, stresses in two mutually perpendicular directions are 6kN/cm 2 compressive and 2
kN/cm2 compressive along with shear stress of 2 kN/cm 2. Determine magnitude of principal
stresses and their directions and maximum shear stress at the point.
Determine the maximum strain energy stored in a solid shaft of diameter 10 cm and of length
1.25 meter, if the maximum allowable shear stress is 50 N/mm2. Take C = 8 x 104 N/mm2.
Calculate the maximum stress induced in a cast iron pipe of external diameter 40 mm, of
internal diameter 20 mm and of length 4 meter when the pipe is supported at its ends and
carries a point load of 80 N at its center.
A beam is simply supported and carries a uniformly distributed load of 40 kN/m run over the
whole span. The section of the beam is rectangular having depth as 400 mm. If the maximum
stress in the material of the beam is 120 N/mm 2 and moment of inertia of the section is 7 x
108 mm4, find the span of the beam.
Explain the neutral axis of the beam. A steel plate is bent into a circular arc of radius 10 m. if
the plate section be 110 mm wide and 20 mm thick find the maximum stress induced and the
bending moment which can produce this stress take E = 2x105 N/mm2.