The document provides recommendations for properly maintaining batteries using specific tools. It lists baking soda, post cleaner, distilled water, goggles, gloves, a voltmeter, hydrometer, and wrench as tools for cleaning and inspecting batteries safely. The document also describes steps for examining the battery exterior for cracks or damage, checking for fluid leaks, inspecting cables and connections, and tightening connections to specifications while wearing protective equipment due to battery acid risks.
The document provides recommendations for properly maintaining batteries using specific tools. It lists baking soda, post cleaner, distilled water, goggles, gloves, a voltmeter, hydrometer, and wrench as tools for cleaning and inspecting batteries safely. The document also describes steps for examining the battery exterior for cracks or damage, checking for fluid leaks, inspecting cables and connections, and tightening connections to specifications while wearing protective equipment due to battery acid risks.
The document provides recommendations for properly maintaining batteries using specific tools. It lists baking soda, post cleaner, distilled water, goggles, gloves, a voltmeter, hydrometer, and wrench as tools for cleaning and inspecting batteries safely. The document also describes steps for examining the battery exterior for cracks or damage, checking for fluid leaks, inspecting cables and connections, and tightening connections to specifications while wearing protective equipment due to battery acid risks.
Proper tools that Trojan recommended for maintaining batteries.
1. Baking Soda - is a great way to remove corrosion from batteries. Just mix a tablespoon of baking soda with enough water to make a paste and pour the mixture over the battery. Let the baking soda sit on the battery for at least 30 minutes, but no more than one hour. 2. Post Cleaner - is the process of cleaning the battery. 3. Distilled water - has no dissolved minerals, salts and impurities which can damage the internal plates of the battery. 4. Goggles and Gloves - to avoid battery acid getting in our eyes and skin. 5. Voltmeter - it is used to make sure the battery is off to avoid getting electrocuted. 6. Hydrometer - tool for measuring the state of charge on a lead-acid battery. 7. Wrench - is used to remove stubborn nuts, or to apply accurate torque.
CAUTION: Always wear protective clothing, gloves and goggles, when handling batteries, electrolyte, and charging your battery.
1. Examine the outside appearance of the battery.
* Look for cracks in the container. * The top of the battery, posts, and connections should be clean, free of dirt, fluids, and corrosion. *If batteries are dirty, refer to the Cleaning section for the proper cleaning procedure. *Repair or replace any damaged batteries. 2. Any fluids on or around the battery may be an indication that electrolyte is spilling, leaching, or leaking out. * Leaking batteries must be repaired or replaced. 3. Check all battery cables and their connections. *Look closely for loose or damaged parts. * Battery cables should be intact; broken or frayed cables can be extremely hazardous. * Replace any cable that looks suspicious. 4. Tighten all wiring connections to the proper specification (see below). Make certain there is good contact with the terminals.