Professional Documents
Culture Documents
SRP Iii
SRP Iii
SRP Iii
SPECIFICATION
For
APPROVAL
( ) Preliminary Specification
( ♦ ) Final Specification
REVIEWED BY
S.M, Yoon
PREPARED BY
H.S, Kim
CONTENTS
Record of Revisions
1. General Descriptions
The AM Tech model SRP- III is a Direct Thermal Printer system. This Printer has a 48mm active
printable area with speed of 25mm/sec. Print Resolution of SRP- III is total 384dots, 8dot per
mm.
The SRP-III is intended to support applications where Credit Authorization Terminals, Receipt
printers, Ticket printers. The SRP-III characteristics provide an excellent quality print for casher
automation products such as POS Printer.
I/F BLOCK
(Serial/Parallel)
SENSOR
[General Characteristics]
The following are general features of the model Mobile Pro Plus;
2. Printer Command
- ESC w n
[Function] To set/cancel double width magnify
[Code] 1BH 77H n (27 119 n)
[Operation]
n= 01H or 31H ------ set double width magnify
n= 00H or 30H ----- cancel double width magnify
- ESC y n
[Function] To set/cancel double height magnify
[Code] 1BH 79H n (27 121 n)
[Operation]
n= 01H or 31H ------ set double height magnify
n= 00H or 30H ----- cancel double height magnify
- CR
[Function] To feed paper after printing operation
[Code] ODH (13)
[Operation]
If there is data in the line buffer, the data will be printed and then paper will be fed.
If there is no data in the line buffer, just ignore.
Default printing amount is 26 dots per line
- LF
[Function] Line Feeding
[Code] OAH (10)
[Operation]
If there is data in the line buffer, the data will be printed and then paper will be fed.
If there is no data in the line buffer, only paper feeding will be conducted.
Default printing amount is 26 dots per line
3. Interface Connections
Mobile Pro Plus Printer employs one interface connections, a 4 pin connector is used for the module
electronics power supply and the communication with host system.
The pin configuration for the connector is shown in the table below.
2) PIN SPECIFICATION
2 D0 I DATA 0
3 D1 I DATA 1
4 D2 I DATA 2
5 D3 I DATA 3
6 D4 I DATA 4
7 D5 I DATA 5
8 D6 I DATA 6
9 D7 I DATA 7
15 N.C.
17 N.C.
4.Mechanical Dimension
5.Appendix