PHENOM 100 NORMAL CHECKLIST PHENOM 100 NORMAL CHECKLIST
COCKPIT SAFETY INSPECTION BEFORE START
Courtesy Light................................................CKD Oxygen Mask Flow and Microphone ............CKD NOTE: Only required for flights with landings after sunset. SIGNS/OUTLET Switch....................... BELTS/ON External Lights.............................. AS REQUIRED Emergency Door Locking Pin............... REMOVE Fuel Quantity and Balance ............................CKD Emergency Door.......... SECURED AND LOCKED Oxygen Pressure for Dispatch.......................CKD Water Barrier………………………..AS REQUIRED TEST Panel................................................... TEST Documents, Manuals, Charts…CHK ON BOARD Thrust Levers................................................. IDLE Maintenance Status........................................CKD Parking Brake.................................................. SET Emergency Equipment…................................CKD Doors........................................................ CLOSED Oxygen Bottle Valve Handle …………..PUSH TO ENG IGNITION Switches............................. AUTO . RESTORE Oxygen SUPPLY CONTROL Knob…. PAX AUTO Oxygen Mask Regulator.......................CKD 100% GEN 1 & 2 Switches……………………….....AUTO AFTER START GPU Button.....................................AS REQUIRED BUS TIE Knob...............................................AUTO GPU..................................................DISCONNECT BATT 1 & 2 Switches ......................................OFF ELEC EMERG Button.............................. PUSH IN Circuit Breakers................................ CKD ALL IN Batteries 1 & 2 Voltage ..................................CKD FUEL PUMP 1 & 2 Switches.........................AUTO FUEL XFR Button........................... PUSHED OUT CAUTION: EACH BATTERY VOLTAGE MUST BE ELT Switch.................................................ARMED AT LEAST 23.8 VOLTS. PUSHER CUTOUT Button.............. PUSHED OUT HYD PUMP Knob...........................................AUTO NOTE: The parking brake must be applied and the Gust Lock Pin......................................... REMOVE main brake must be released for battery voltage Rudder Gust Lock..................................RELEASE check. WSHLD 1 & 2 Switches...................................OFF ADS/AOA Knob ............................................AUTO ELEC EMERG Button.......................... PUSH OUT ENG 1 & 2 Switches.........................................OFF External Lights...............................AS REQUIRED WINGSTAB Switch...........................................OFF AFCS Control Unit ..........................................SET INSP LIGHT Switch .........................................OFF Altimeters (pilots and IESI) ............SET & X-CKD LDG GEAR Lever ..............................................DN Transponder.....................................................SET PRESN MODE Switch ..................................AUTO Takeoff Speeds ...............................................SET BLEED Knob.................................................BOTH Takeoff Data ....................................................SET DUMP Button.................................. PUSHED OUT LFE ...................................................................SET AIR CONDITIONING Panel.............AS REQUIRED Flight Controls..................................... CKD FREE SHUTOFF 1 & 2 Buttons.................................CKD Trims.................................................... CKD & SET BOTTLE Switch................................................OFF START/STOP Knobs.....................................STOP NOTE: It is recommended that the selected pitch Flap Lever......................................................ZERO trim position (digital readout) is equal to the SPEED BRAKE Switch (if available …….CLOSE CG %MAC. Parking Brake...................................................SET Seats and Belts ..................................CONDITION Flap ...........................................................SET T/O
POWER UP DDPP
BATT 1 & 2 Switches ....................................... ON