Professional Documents
Culture Documents
Camera Setup: Electrical
Camera Setup: Electrical
Camera Setup: Electrical
Camera Setup
NOTE
Figure 22802
The following buttons are used to scroll through the
The keyboard on the monitor consists of eight buttons various setup menus.
that facilitate navigation through the various setup
5. Option
menus. The following is a description of each button
and its function. Press the option button to return to the previous menu.
1. Camera Selection 6. Selection/Setting -
Press the camera selection button once. The camera Press the selection/setting - button to go to the next
LED will blink, indicating the manual camera override is menu option.
active. Use the minus (6) and plus (7) buttons to select
7. Selection/Setting +
the camera. You can select a different camera by
switching off this function by pressing the plus and mi- Press the selection/setting + button to go to the previ-
nus buttons. ous menu option.
8. Enter
Press the enter button to select or activate the high-
lighted option.
23
ELECTRICAL
Camera Setup
Figure 22804
2. Use the option (5), minus (6), plus (7) and enter (8)
buttons to scroll through the service menu.
3. Press the enter button (8) to activate the camera
settings menu. When entering the menu, use the
minus (6) and plus (7) buttons to select the camera
Figure 22803 (C1) to configure and press the enter (8) button.
The yellow cursor will jump to the list of items. Use
NOTE the minus and plus buttons to select the item to ad-
If the standby menu cannot be toggled, ensure the just, and press the enter button. If the selection op-
forks are above staging. If the standby menu still can- tion is ON/OFF, it will toggle between on (repre-
not be toggled, go into the keyboard menu and ensure sented by a large dot) and off (represented by a
it is not locked out (represented by a large dot instead small dot). If the option is a numeric value, it is pos-
of a small one). sible to change the value with the minus and plus
buttons. Press the enter button to store the new
2. Press the enter button (8) a second time and the setting. Refer to Figure 22805.
monitor will go into standby. A black screen will
now be shown. When the blue wire is connected to
BNEG (above staging), the monitor will be acti-
vated and the camera picture will be shown on the
screen. When the blue wire is either disconnected
(open) or connected to +BV (below staging), the
monitor will go back to standby and show a black
screen again.
Figure 22805
24
ELECTRICAL
Camera Setup
Figure 22806
Figure 22807
2. In the keyboard lock menu, the following options
can be toggled ON (represented by a large dot)
and OFF (represented by a small dot).
25
ELECTRICAL
Camera Setup
NOTE
All user settings will be lost when the factory defaults
are reset.
Default Settings
This option under the system setting menu opens the
default settings menu. If the restore defaults option is
selected, the factory settings will be reset. The restore
defaults option can be used to get the service techni-
cian back to a known state. Refer to Figure 22808.
Figure 22808
26