Professional Documents
Culture Documents
EW210D - Brake Accumulator Charging Pressure, Adjusting
EW210D - Brake Accumulator Charging Pressure, Adjusting
Tools:
88830213 Measuring equipment
WARNING
Hot hydraulic oil and hydraulic oil under pressure may result in severe personal injuries
Checking
1. Warm up hydraulic oil to operating temperature, see Hydraulic system, warming up.
Figure 1
Check point bar
5. On the pressure gauge select display mode for max. pressure measuring.
8. Press the digging brake pedal at least three times down and wait approx. 20s.
10. Read off the max. pressure value on the pressure gauge and compare with the data in specification, see Hydraulic
pressure, specifications
Adjusting
Figure 2
Cover plate under cabin
12.
Figure 3
Brake valve with accumulator
1 Protection cap
2 Adjusting screw
3 Lock nut
38 Brake valve
74 Brake accumulator
Remove cap (1) from adjusting screw (2).
13. Loosen the lock nut (3) and turn adjusting screw (2).
Turn adjusting screw (2) clockwise to lower or counterclockwise to raise the pressure.
Tighten the lock nut (3).
NOTE!
½ turn corresponds to approx. 5 bar.
15. Repeat the necessary steps until the required pressure is adjusted.