Professional Documents
Culture Documents
BTS30 StormBox
BTS30 StormBox
BTS30 StormBox
-1-
Specifications What's in the Box
Bluetooth version: V4.2
Bluetooth profile: A2DP, AVRCP, HFP, HSP
Driver: 2 x Φ45mm, 2 x Passive radiator
Output power: 2 x 12W Micro USB Cable
Signal-to-noise ratio ≥ 80dB
Frequency response: 70-20KHz
Battery: ( 3.7V 2600mAh ) x 2
Music play time: Up to 20 hours (varies by volume PORTABLE WIRELESS SPEAKER STORMBOX
Charging
AUX-IN
Volume + Button Power Button & Indicator
Battery level Indicator Bluetooth Pairing
MFB Button Bluetooth Button
Volume - Button XBASS Button & Indicator
AUX-IN Port
2
Charging Port
Bluetooth ON Tribit StormBox
1 3
-4- -5-
Wireless Daisy Chain with Two StormBox Step2: Pair/Connect the Speaker A
Step 1Connect the Speaker A and B
>5s
Tribit StormBox
Speaker A Speaker B
Speaker A
Keep Speaker A and B power on
Press the Bluetooth button on Speaker A at least 5s till the
tone comes up Note: Same as normal Bluetooth pairing
-6-
Wait for the Speaker A and B connecting success with tone -7-
Step3: Enjoy music with two StormBox Function Button Operation
Pair a Bluetooth Bluetooth Press the button to manually
Device Button enter pairing mode
Volume Up Volume + Press the button to increase
the volume level
Volume Down Volume - Press the button to decrease
the volume level
Play/pause MFB Press once the button
Next track MFB Double press the button
Previous track MFB Press the button for 3 times
Tribit StormBox answer/end the MFB Press once the button
incoming call
Reject an MFB Press and hold the button for
Buttons incoming call 2s
Voice dial MFB Press and hold the button for
Function Button Operation function 2s to activate (your device must
Power ON/OFF Power Button Press the button to turn support this function)
on/off the speaker XBASS XBASS Press the button to switch
-8- Bass and normal mode -9-
Indicators Reset
Indicator Status If this speaker has any problem, you can try to
Power
Blue indicator flashes slowly Reconnection mode press and hold Volume + and Volume - buttons
indicator Blue indicator flashes quickly Bluetooth pairing mode simultaneously for 5s to reset this speaker and
Blue indicator keeps sturdily on Connected
XBASS White indicator lights up Bass mode is activated remove the old pairing in your Bluetooth device,
indicator and then pair again.
Four white indicators light up Remaining battery
power: 71% ~ 100%
Battery Three white indicators light up Remaining battery
Customer Service
indicator power: 51% ~ 70% 18-month limited warranty
Two white indicators light up Remaining battery
power: 26% ~ 50% For FAQS and more information, please visit:
One white indicator lights up Remaining battery Email: support@tribitaudio.com
power: 10% ~ 25%
A red indicator lights up Low battery power www.tribitaudio.com
(<10%), Please recharge
the speaker.
-10- -11-
FCC Statement try to correct the interference by one or more of the following
Changes or modifications not expressly approved by the party measures:
responsible for compliance could void the user's authority to
operate the equipment. Reorient or relocate the receiving antenna.
This equipment has been tested and found to comply with the Increase the separation between the equipment and receiver.
limits for a Class B digital device, pursuant to Part 15 of the FCC Connect the equipment into an outlet on a circuit different from
Rules. These limits are designed to provide reasonable that to which the receiver is connected.
protection against harmful interference in a residential Consult the dealer or an experienced radio/TV technician for
installation. This equipment generates uses and can radiate help.
radio frequency energy and, if not installed and used in
accordance with the instructions, may cause harmful This device complies with part 15 of the FCC rules. Operation is
interference to radio communications. However, there is no subject to the following two conditions:
guarantee that interference will not occur in a particular
installation. If this equipment does cause harmful interference (1) This device may not cause harmful interference.
to radio or television reception, which can be determined by (2) This device must accept any interference received, including
turning the equipment off and on, the user is encouraged to interference that may cause undesired operation.
-12- -13-