Professional Documents
Culture Documents
Clips para Rejillas EXIPLAST
Clips para Rejillas EXIPLAST
ting Clips
Exiplast supplies a number of different types of 316SS clips to
attach its various molded and pultruded fiberglass gratings to
supporting members.
Clips
C clips were specifically designed to tie two panels
of molded fiberglass gratings together to minimize
differential defections when their joints fall between
supports. C clips are also used in fiberglass grating
leg systems for panel abutments. Lower nut is wel-
ded to clip so installation is from top side
of fiberglass grating floor.
W Clips
This 1 ½” diameter fastener is used for holding
down plates and covered fiberglass gratings. The W
clip’s recessed center allows the fastener to sit flush
with this ADA compliant (< ¼” high) hold down clip.
PAW Clips
For the ultimate in holding capacity of square mesh mol-
ded fiberglass grating, the exclusive American Grating PAW
clip should be specified. These clips clamp 4 load bars to
the support, offering excellent bidirectional resistance to
loads from seismic or other lateral forces.
T Clips
T clips offer the solution for below-surface attachment to
pultruded fiberglass gratings. When used these FRP clips
should be specified in pairs as shown.
M Clips
M clips or saddle clips clamp 2 fiberglass grating load bars
to the support. This provides excellent holding capability
and because of this, are recommended for stair treads and
most molded and pultruded fiberglass gratings
T Clips
T clips offer the solution for below-surface at-
tachment to pultruded fiberglass gratings. When
used these FRP clips should be specified in pairs
as shown.
L Clips
This lighter duty clip should be specified to hold
one load bar to the support for lighter duty loads.
It is available for molded and pultru-
ded fiberglass gratings.